Transcription
INSTALLATION AND OPERATING INSTRUCTIONSfor all HydrocarbonWTRF Refrigerator Freezer Models809-172A 07/19/20223779 CHAMPION BLVD, WINSTON-SALEM, NC 27105Phone: (888) 845-9800 Fax: (800) 253-5168 Web: beverage-air.comSEE BACK COVER FORWARRANTY REGISTRATION
User Manual for WTRF Refrigerator FreezerBeverage AirWELCOMECongratulations on your purchase of Beverage-Air foodservice equipment. Every employee welcomes you to thefamily of satisfied Beverage-Air customers.From the earliest stages of production design, to focusedsteps in fabrication and assembly, rigid standards ofquality are maintained by our staff of skilled employees.Beverage-Air strives to supply superior products throughstrict quality control guidelines exceeding industrystandards, this means that each unit, given the propermaintenance will provide years of trouble free experienceto its owner.Additionally, Beverage-Air food service equipment hasone of the best warranties in the food service industry,and backed by a professional staff of service techniciansacross the country.We thank you for your choice and confidence in BeverageAir Equipment.For part inquiries or orders please call our TechnicalService Department at (800) 684-1199. 8:00 AM to 5:00PM EST.Important Information PLEASE READ THESE INSTRUCTIONS CAREFULLYBEFORE INSTALLING OR USING, IF RECOMMENDEDPROCEDURES ARE NOT FOLLOWED, WARRANTYCLAIMS MAY BE DENIED. Your warranty registration information is located withthis manual. Please complete the card and submit it toBeverage Air within TEN days of installation. Failureto properly register equipment may limit or void thewarranty. Beverage Air reserves the right to changespecifications and product design withoutnotice. Such revisions do not entitle the buyer tocorresponding changes, improvements, additions, orreplacements for previously purchased equipment.ContentsSafety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Cleaning and Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 24Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5Drawer Cleaning and Maintenance . . . . . . . . . . . . . . . . . . . . 25Product Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6Condenser Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26Clearance and Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7Methods For Cleaning Stainless Steel . . . . . . . . . . . . . . . . . . 27Unpacking and Set Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8Help . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28Shelf Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9For The Service Tech - R290 . . . . . . . . . . . . . . . . . . . . . . . . . . 29Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10For The Service Tech - Wiring Diagrams Section . . . . . . . . 30Using The Unit with a Danfoss Controller . . . . . . . . . . . . . . . 11Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33Sequence of Operations - Refrigerator Section . . . . . 12Limited Warranty (continued) . . . . . . . . . . . . . . . . . . . . . . . . . 34Sequence of Operations - Freezer Section . . . . . . . . . 16Using The Unit with an Eliwell Controller . . . . . . . . . . . . . . . 20Sequence of Operations - Refrigerator Section . . . . . 212Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirSAFETYThis appliance has been designed with your safety in mind. It has many features to keep you from being harmed. However,safe operation and maintenance are your responsibilities. This appliance is not intended for use by persons (includingchildren) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they havebeen given supervision or instruction concerning use of the appliance by a person responsible for their safety.Children should be supervised to ensure that they do not play with the appliance.CAUTIONUse: When using this unit, please: Move it carefully. If on casters be sure the castersdo NOT run over the power cord. Lock the casters when in use. Seek help. This machine is heavy! Be sure to movewith enough help to avoid tipping or dropping thecabinet. Prevent children from playing in or on the cabinet.Persons unable to use this product must beprevented access. Follow all instructions. There are many safetylabels and directions on the unit. Heed them. Watch your fingers. There may be pinch points nearthe door hinges.CAUTIONMaintenanceDo NOT:Do ALWAYS Clean a frozen evaporator with a sharp object Clean a dirty condenser with a sharp object.Use a Beverage Air recommended technician certifiedto repair R290 equipment. Store gasoline, kerosene or any other flammablematerial near the cabinet. Use ONLY Beverage Air factory service parts. Use ofnon OEM parts can be dangerous because of the designchanges needed to safely use R290.Important Information to AddRecord the model number, serial number and the date of installation here for future reference. The model and serialnumbers are on the unit's serial number dataplate, which is located on the left inside wall.Model NumberSerial NumberDate of InstallationPurchased FromCAUTIONRev. 07/22WARNINGObserve the Caution and Warning notices. They are indicators ofimportant safety information. Keep this manual for future reference.Beverage Air3
User Manual for WTRF Refrigerator FreezerBeverage AirNote: The top panel of this unit can be damaged by standing on it.Damage like that is NOT covered by warranty.WARNINGRisk of PersonalInjury From FallingStay OFF top of unitNO STEP NO STEP NOSTEPFor your protection, safety labels have been placed atimportant locations on the cabinet. Be SURE to read andfollow their instructions.4Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirIMPORTANT INFORMATIONThis unit is intended to be used in a commercial application. That includes bars and restaurants.If installed in a residence some commercial service companies may not be able to service it on site.The manufacturer has designed and produced this machine with the finest in materials. The manufacturer assumes noliability for units that have been altered in any way. Alterations or part substitutions will void the warranty.LimitationsThe machine is designed for use indoors in a controlledenvironment. It must be kept dry, not overheated orsubjected to excessive cold. May only be connected toa dedicated electrical circuit. Extension cords are notpermitted.MinimumMaximumVoltage103.5126.5Room Air Temp60º F100º FAir Flow, All Models regardless of section, door count or door material.Agency ApprovalsThese marks appear on the dataplate or serial tag, locatedin the inside of the left wall. The dataplate also containsthe model and serial numbers as well as electricalrequirements.Rev. 07/22Beverage Air5
User Manual for WTRF Refrigerator FreezerBeverage AirPRODUCT INFORMATIONCabinet Dimensionsw x d x h (Inches)DoorCountFull LoadAmps RefrigeratorFull LoadAmps FreezerWTRF48AHC48 x 32 x 39 5/8222.5WTFR48AHC48 x 32 x 39 5/8222.5ModelPower CordPlug (NEMA)Refrigerant Type /Charge (g) / Charge(oz)(2) 5-15PR-290 / 60 / 2.03Flat top models are 4 inches shorter. Height includes casters. WTRF models will have the refrigerator on the left side, freezer on the right. WTFR models will have the freezer on the left side, refrigerator on the right. The refrigerator section will maintain product temperature between 36 and 38 degrees F. at the factory setting of38.0F. The freezer section maintains the temperature at 0.0F and below. All models are 115 volts, 60 Hz AC. ALWAYS REFERENCE YOUR EQUIPMENT DATA PLATE AMPS, REFRIGERANT AND REFRIGERANT CHARGE FOR THEMOST UP TO DATE AND ACCURATE VALUES.6Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirCLEARANCE AND PLACEMENT2"REARMINIMUMCLEARANCE0"LEFT/RIGHT entConsider the following when selecting a location for your Refrigerator:Clearance:0" - Top0" - Left0" - Right2" - Rear3" - BelowFloor Load: The floor on which the Refrigerator is located must be even and level, free from vibrations, and strong enoughto support the combined weights of the unit and maximum product load.Ventilation: Grille area at front must be free and clear of any object or wall.Power Outlet: The installation of this appliance requires a dedicated power outlet located within the length of the unit'spower cord and be accessible for the purpose to disconnect power.Rev. 07/22Beverage Air7
User Manual for WTRF Refrigerator FreezerBeverage AirUNPACKING AND SET UPCarefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage issuspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim.Do NOT contact the manufacturer.UncratingTools Needed: ¾” box wrench, adjustable wrench, level,flat head screw driver, and box cutter.1.Cut the stretch wrap along a corner post and removethe cardboard top capping and the corner posts.2. Discard stretch wrap and any cardboard that will notbe recycled.Note: additional clear plastic protective wrap isapplied directly to any product with a glass door.3. Move unit as close to final position as possible beforeremoving the skid.Note: The skid must be removed before the casters orlegs can be attached.Do NOT tip unit on its front or sides. If tipped onto theback, unit must not be started for 3 hours.Skid Removal and Caster AttachmentTip the unit forward and remove the skid.suitable material.4. Thread the stem casters or legs into the ½ -13 holes inthe bottom of the cabinet. Tighten by hand as muchas possible.WARNINGRisk of personal injury.Unit must be securely supportedwhile attaching casters or legs.1.Remove the shipping bolts using the ¾” box wrenchwhile cabinet is held in one direction. Repeat the processwhile the cabinet is held in the opposite direction.2. None of the threads on the leg or caster stem shouldbe visible once screwed in.5. Once the caster or leg cannot be turned any further,use a 3/4 inch wrench to tighten the nut in betweenthe mounting plate and the wheel of the caster untilsnug.6. Repeat this procedure with unit secured in theopposite direction so as to access the remaining legs/casters7.3. Tilt the cabinet in one direction approximately 8” andblock it securely with pieces of 2x4 lumber or otherIf plate casters or legs are installed instead of stemcasters or legs, then repeat step 3 above and securethe plate with either #14 AB screws, or ¼-20 screws,depending upon which are required.Leveling:Cabinets must be leveled when installed. Level should bemeasured on the headrail.holes located on the bottom of the case.Failure to level your cabinet may result in door notsealing, closing correctly, or condensed water draining notdraining properly.For cabinets with legs, rotate the foot of the leg with anadjustable wrench to achieve desired height for leveling.For cabinets with casters, leveling can be achieved byplacing large washers in between the ½’ stud and the8CAUTIONDo NOT loosen casters to levelthe cabinet. Casters MUST betightly secured to cabinet for fullstrength.Install or attach any accessories that will be usedRemove any plastic covering the stainless steel.Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirSHELF INSTALLATION1.Determine the proper location for the shelf clips.7.2. Insert the top tab of the shelf clip into the desiredhole of the pilaster. The retaining tab MUST be facingup as shown.3. Rotate the clip downwards and insert the bottom tabinto the matching hole in the pilaster. The clip mayneed to be squeezed slightly during installation.4. Install all remaining clips.5. Install shelves onto clips with the product retentionbar facing up. Be careful not to dislodge clips duringinstallation.Confirm that the shelf is resting on ALL 4 clips andthat the clips are securely attached to the pilasters.8. Improper shelf clip installation could cause the shelfand / or the product on it to fall, resulting in damageto the unit and possible bodily injury.9. Do NOT overload the shelves. The unit is designed touse all shelves that are supplied in an equally spacedmanner. Contact Beverage Air customer service iffewer shelves or a different configuration to ensureshelf overloading will not occur.6. Place shelves so that the retaining tab on the clipcaptures the shelf as shown.Rev. 07/22Beverage Air9
User Manual for WTRF Refrigerator FreezerBeverage AirELECTRICALThis is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on themachine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers.Note: Do not connect to GFI / GFCI outlets. Connection to that type of outlet can result in product loss due tounsafe cabinet temperature when GFI device trips from moisture.Power CordThis 115 volt model is equipped with a cord and 5-15P plug.If the power cord becomes damaged, it must be replacedwith the identical cord.Follow All National and Local CodesThis unit must be grounded. Do not use extension cordsand do not disable or by-pass ground prong on electricalplug.Initial Start UpPlug the power cord into the proper power supply.The cabinet will soon begin to blow warm air out of thetop area, and cool air will flow from the inside blower.The cabinet temperatures have been set at the factoryand should not need adjustment, however if changed, thestandard refrigerator setting is 38º F., while the standardfreezer setting is 0oCare must be taken whenever moving or servicing theunit. The refrigerant is contained in a sealed system, but ifreleased it may be flammable.10Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirUSING THE UNIT - DANFOSS CONTROLLEROperation is simple, just keep it connected to the correctpower supply and the refrigerator will maintain theinternal temperature it has been set to. Keep the doorsclosed as much as possible to avoid unnecessary run time.There are two controllers, both in the lower front grille ofthe cabinet. For WTFR models, the left controller is forthe freezer section and the right one is for the refrigerator.For WTRF models, the left controller is for the refrigeratorsection and the right one is for the freezer. Each controllerdisplays the current internal temperature for its section.Adjusting the set temperature lower will NOT cause thesystem to lower the temperature faster. When on, therefrigeration system is always operating at maximum.Each section will automatically defrost as needed, there isno set time for defrost. Push and immediately release the"melting" or defrost button for a manual defrost.Note: Holding the defrost button in too long will shut thecontroller off.The internal fan will be on whenever the appliance isconnected to power.The compressor and condenser fan motor will only be onwhen the controller senses an increase in internal cabinettemperature passed the set point.For best results, make certain the unit remainspowered and has achieved the desired set pointbefore loading it with product. Pull down time willvary depending upon the type of unit and ambientconditionsDefrostThe refrigerator temperature was set at the factory at 38ºF, and the freezer temperature was set at 0o F., but youcan adjust it to your own selected temperature.38.0SelectIncreaseoFDecreaseIn most cases the only thing displayed will be the cabinet temperature. When something other than normal operation hasoccurred, a message will be shown.Message DisplayedWhyWhat to dodEFUnit is defrostingNothing. Normal operation.HiCabinet temperature too warmConfirm doors or drawers are closed.dOrDoor is openClose door, if message does notchange, call for service.LEACompressor run time too longCheck doors closed. If yes, call forservice.E01, E02, E03, E04Sensor unplugged or has failedCall for service.Rev. 07/22Beverage Air11
User Manual for WTRF Refrigerator FreezerBeverage AirSEQUENCE OF OPERATIONS REFRIGERATOR SECTION - DANFOSS CONTROLLERThe refrigerator operates based on the air temperature measured by the probe located at the return air.ONCOMPONENTOPERATIONCOMPRESSORCompressor turnson when the airtemperature at theprobe is above thesum of the set point 2OFFCONTROLLER ACTIONOPERATIONThe CompressorContact is energizedCompressor turnsoff when the airtemperature at probe isequal to or less than the(ERC 112 – Terminal #1)set point -2CONTROLLER ACTIONThe CompressorContact is deenergized(ERC 112 – Terminal#1)The Condenser Fanturns off when theCompressor is notrunningThe Condenser Fanis wired directly tothe Compressor, notthrough the controllerEVAPORATORFANThe Evaporator Fanruns continuously inrefrigerators. Whenthe unit is pluggedin, the EvaporatorFan will run.The Evaporator Fan isconnected directly toincoming power, notthrough the controller.The Evaporator Fan runscontinuously. When theunit is plugged in, TheEvaporator Fan will run.The Evaporator Fan isconnected directly toincoming power, notthrough the controller.CompressorConditionEvaporatorFanThe Condenser Fanis wired directly tothe Compressor, notthrough the controllerCondenser FanCONDENSER FANThe Condenser Fanturns on whenthe Compressor isrunningCabinet Temp Set point 2ONONONCabinet Temperature Set point - 2OFFOFFONDefrostOFFOFFON12Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirREFRIGERATOR SECTIONElectronic ControllerDEFROST (ESC)UPSELECT (OK)DOWNControl Panel DisplayDefrost LEDAlarm LEDOn fixed:Defrost activeOn fixed:ALARM PresentOff:Defrost is offFlashing:ALARM SilencedOff:No AlarmFan LEDCompressor LEDOn fixed:Fan activeOn fixed:Compressor activeOff:Fan OffFlashing:Delay, protection or activation blockedOff:No AlarmNOTE: When switched on, the instrument panel performs a lamp test for a few seconds.Keyboard FunctionsUPDOWNDEFROST (ESC)SET (ENTER)Quick press and releaseQuick press and releaseQuick press and releaseQuick press and release Increases Set Point Decreases Set Point Activates manual defrost Toggles lights on/offLong press and releaseLong press and releaseLong press and releaseLong press and release Increases display brightness Decreases display brightness Controller enter stand-by mode Toggles display F/ CNote: When the controller is in a Standby Mode, ablue dot will be displayed as shown here. To switchout of Standby Mode, push and hold the Defrostbutton until the display reads ON.Rev. 07/22.Beverage Air13
User Manual for WTRF Refrigerator FreezerBeverage Air0123ÿ567869ÿ 3ÿ ÿ 9ÿ5 9 ÿ 923ÿ 2 236 2 3REFRIGERATOR SECTION14Beverage AirRev. 07/22
0123ÿ567869ÿ 3ÿ ÿREFRIGERATOR SECTIONUser Manual for WTRF Refrigerator Freezer 2 236 2 3Beveragae Air()* ,ÿ./ÿ01023ÿ4561789:;ÿ 9348ÿ024ÿ9;ÿ 2: 2488ÿ?@A@ÿ/:1C42ÿ:/ÿ D4ÿ 02034 42ÿ 0E14FGÿ D4ÿ01023ÿ98ÿ;: ÿ89 ;014CHRev. 07/22 ÿ Beverage Air!" # %15&'
UserManualManualforforPFIWTRFRefrigerator FreezerUserFreezersBeverage AirBeverage-AirSEQUENCEOPERATIONSFREEZER SECTION - DANFOSS CONTROLLERSEQUENCEOFOFOPERATIONSFREEZERThe freezer operates based on the air temperature measured by the probe located at the return air.ONCOMPONENT OPERATIONOFFCONTROLLERACTIONCompressor turnson when the airtemperature at theprobe is above thesum of the set point 2.5The Compressor Contactis energizedCONDENSER FANThe CondenserFan turns on whenthe Compressor isrunningEVAPORATORFANThe EvaporatorFan turns on whenthe Compressor isrunning and thedoors are closed.COMPRESSORCompressor turnsoff when the airtemperature atprobe is equal toor less than the setpoint – 2.5The Compressor Contactis de-energizedThe Condenser Fan iswired directly to theCompressor, not throughthe controllerThe Condenser Fanturns off when theCompressor is notrunningThe Condenser Fan iswired directly to theCompressor, not throughthe controllerThe Evaporator Fan iswired to the Fan ContactThe Evaporator Fan The Evaporator Fan isturns off when thewired to the Fan ContactCompressor is notrunning, and whendoor is opened(ERC 112 - Terminal #5)while Compressor isrunning(ERC 112 - Terminal #1)(ERC 112 - Terminal #5)When either thedefrost is notscheduled or thetemperature atdefrost probehas reached thedefrost terminationtemperature.The Defrost HeaterThe Defrost Heaterwill activateContact is energizedon cumulativeDEFROST HEATER Compressor runtimeof 6 hours, and whentemperature drops(ERC 112 - Terminal #6)too lowFACE/DOORHEATERS1216The Door/Face Heaterare wired to theCompressor Contact(ERC 112 - Terminal #1)The Defrost HeaterContact is de-energized(ERC 112 - Terminal #6)The Face & DoorHeaters turnoff when theCompressor is notrunningThe Door/Face Heaterare wired to theCompressor ContactThe light will turnoff when theThe Light Contact is deenergized(ERC 112 - Terminal terDrain HeaterLightsis pressed (or when(ERC 112 – Terminal #4)the door is closedwith solid doors)CondenserFanThe light will turn on The Light Contact isenergizediswhen thepressed (or when thedoor is opened with (ERC 112 – Terminal #4)solid doors)(ERC 112 - Terminal #1)CompressorLIGHTThe Face & DoorHeaters turnon when theCompressor isrunningCONTROLLERACTIONOPERATIONCabinet Temp Set point 2.5ONONONOFFONONON or OFFCabinet Temperature Set point - 2.5OFFOFFOFFOFFOFFONON or OFFDefrostOFFOFFOFFONOFFONON or OFFBeverage-AirBeverage AirRev. 07/21Rev. 07/22
8C/-40ÿD412ÿEÿF40ÿ2,/-0ÿGÿHIJKL KL KL K77 KL KL KLÿ,3ÿK77K77 K77 K77 K77 K77 KL KLÿ,3ÿK77 8C/-40ÿD4124380M34ÿNOÿF40ÿ2,/-0ÿPÿHIJUser Manual for WTRFRefrigeratorFreezer;4 3,50K77 K77 K77 KL K7Beveragae7Beverage-AirKL KLÿ,3ÿAirK77User Manual for PFI Freezers0123ÿ567869ÿ 3ÿ ÿ322 231QRÿSTUVWXYTÿ[WXUVWRRSV 2 236 2 3FREEZER SECTION ,123455,3 ,-.4-543ÿ789:82,380,3ÿ78;4 3,50ÿ 4804378 4?;,,3ÿ 48043;38/-ÿ 48043 ,-./0/,-ÿ ÿ @/AB05 ÿ 8C/-40ÿD412ÿEÿF40ÿ2,/-0ÿGÿHIJKL KL KL K77 KL KL KLÿ,3ÿK77[WXUVWRÿ] XSK77Rÿ ỲaRK7 7b K77 K77 K77 KL KLÿ,3ÿK77 8C/-40ÿD4124380M34ÿNOÿF40ÿ2,/-0ÿPÿHIJ;4 3,50K77 K77 K77 KL K77 KL KLÿ,3ÿK77;4 3,50ÿ@9;de831ÿ@9;fgÿijklmnkopqrsÿtusvwk QRSTUVWXYTÿ[WXUfgÿiVjWRklRmSVxyxz{ÿ pkrkgsÿf}mnkopqrsÿvrÿq} tr vg mf}m ÿ 78-ÿ@9;fgÿijklm tgÿtusvwkf}m ÿ tgÿf}xyxz{ÿ v kgukl qÿx tp ,123455,3ÿ@9;fgÿijklmq pkrrqpÿtusvwk tr vg m nk t ÿ pqskusv qgÿqpÿtusvwtsvqgÿ qu klUser Manual for PFI Freezersf}m qÿx tp Beverage-Air ÿ ¡ÿ §ÿ̈¡ ÿ ÿ ¡ ª« ¡ ÿ ¡ ÿ̄ ª ̈ª ÿ ÿ̄ ÿ ÿ ̈ªÿ ÿ ÿ ¡§ ÿ[WXUVWRÿ] XSRÿ ỲaR bÿKeyboard Functions;4 3,50ÿ@9;Ïde831ÿ@9;²³ µ¶ÿ̧¹µfgºÿÿ́i¹jkµlÿ»m³º ¼³½½µ¼nkÿ¾¿oÿp¾ºqrÿÀsÿÿtÁu svÀwºkÂÃÄÿųµÆÿÀÿ fgÿijklmxyxz{ÿ pkrkgsýǵÿ³ ¿p¹qr³sȺÿ¹µ¼µÊÿ˳ÿ¿È¾ »¹ÿÿvrÿq} tr vg mxyxz{ÿ v kgukl³Ç ÿ³ÌÿÁ ÿ́¹µÿ͵̼³¿ ÿf}m(ESC) qÿx tp DEFROSTUPÃÇ ³ºÿǺ ¿ÿβÊ,123455,3ÿ@SET9; (ENTER)Quick press and release Quick press and releaseQuick press and releasefgÿijklmf}m tgÿtusvwk tgÿf}fgÿijklmq pkQuickrrqpÿtpressusvwkand release tr vg m nk t ÿ pqskusvqgÿ qTogglespÿtusvwtlightssvqgÿ on/off qu klLong press and releaseLong press and releaseLong press and releasef}m qLongÿx tppress and release Controller enter stand-by mode Increasesdisplaybrightness Decreasesdisplaybrightness ÿ ¡ÿ §ÿ̈¡ ÿ ÿ ¡ ª« ¡ ÿ ¡ ÿ̄ ª ̈ª ÿ ÿ̄ ÿ ÿ ̈ªÿ ÿ ÿ ¡§ Toggles display F/ C Increases Set Point ÿ Decreases Set Point Activates manual defrost!"!# %!&'(#Control Panel Connections²³ µ¶ÿ̧¹µºÿ́¹µÿ»³º ¼³½½µ¼ÿ¾¿ÿ¾ºÿÀÿÁ ÀºÂÃÄÿųµÆÿÀÿýǵÿ³ Ⱥÿ¹µ¼µÊÿ˳ÿ¿È¾ »¹ÿ³Ç ÿ³ÌÿÁ ÿ́¹µÿ͵̼³¿ ÿÃÇ ³ºÿǺ v.07/21Rev.07/22 ÿ Beverage-AirBeverageAir!"!# %!&'(#)*Ï1317)*
User Manual for WTRF Refrigerator Freezer0123ÿ567869ÿ 3ÿ ÿ 9ÿ5 9 ÿ 923ÿFREEZER SECTION18)*Beverage Air!"!# %!&'(#Air 2Beverage 236 2 3Rev. 07/22 ÿ
0123ÿ567869ÿ 3ÿ ÿFREEZER SECTIONUser Manual for WTRF Refrigerator Freezer 2 236 2 3Beveragae Air()* ,ÿ./ÿ01023ÿ4561789:;ÿ 9348ÿ024ÿ9;ÿ 2: 2488ÿ?@A@ÿ/:1C42ÿ:/ÿ D4ÿ 02034 42ÿ 0E14FGÿ D4ÿ01023ÿ98ÿ;: ÿ89 ;014CHRev. 07/22 ÿ Beverage Air!" # %19&'
0123ÿ567869ÿ 3ÿ ÿ 9ÿ5 9 ÿ 923ÿUser Manual for WTRF Refrigerator Freezer 2 236 2 3Beverage Air ,./ÿ123ÿ .-1ÿ4ÿ35-6355ÿ78.1985539USING THE UNIT - REFRIGERATOR SECTION - ELIWELL CONTROLLER)*20!"!# %!&'(#Beverage Air ÿRev. 07/22
RefrigeratorwithEliwellController FreezerUserManual forWTRFRefrigeratorBeverage-AirBeveragae AirSEQUENCE- REFRIGERATOR SECTION - ELIWELL CONTROLLERSEQUENCE OFOF OPERATIONSOPERATIONS REFRIGERATORThe refrigerator operates based on the air temperature measured by the probe located at the return air.ONCOMPONENTOPERATIONCOMPRESSORCompressor turns onwhen the airtemperature at theprobe is above thesum of the set point 4The CondenserFan turns on whenCONDENSER FANthe Compressor isrunningCONTROLLERACTIONThe Compressor Contactis energized(EW 978 - Terminal#1)The Condenser Fan iswired directly to theCompressor, not throughthe controllerThe Evaporator Fan iswired to constant powerEVAP FANThe EvaporatorFan turns on whenthe unit ispowered on.LIGHTThe Light Contact isThe light will turn onenergizedwhen the downbutton ispressed (or when the(Ew 978 – Terminal #2)door is opened withsolid doors)Rev. 07/22OFFOPERATIONCONTROLLERACTIONCompressor turnsoff when the airtemperature atprobe is equal toor less than theset pointThe Compressor Contactis de-energizedThe Condenser Fanturns off when theCompressor is notrunningThe Evaporator Fanturns off when theunit is unpluggedor put into standby.The Condenser Fan iswired directly to theCompressor, not throughthe controllerSome models will bewired to the fan relay(EW 978 - Terminal#3)(EW 978 - Terminal #1)The Evaporator Fan iswired to constant powerSome models will bewired to the fan relay(EW 978 - orFanLightsThe Light Contact is deThe light will turnoff when the down energizedbutton ispressed (or when thedoor is closed with(Ew 978 – Terminal #2)solid doors)Cabinet Temp Set point 4ONONONON or OFFCabinet Temperature Set point - 4OFFOFFONON or OFFDefrostOFFOFFONON or OFFBeverage Air21
User Manual for WTRF Refrigerator Freezer0123ÿ567869ÿ 3ÿ ÿ 9ÿ5 9 ÿ 923ÿREFRIGERATOR SECTION22)*Beverage Air!"!# %!&'(#Beverage Air 2 236 2 3Rev. 07/22 ÿ
User Manual for WTRF Refrigerator Freezer0123ÿ567869ÿ 3ÿ ÿ 9ÿ5 9 ÿ 923ÿREFRIGERATOR SECTIONRev. 07/22 ÿBeverage Air!"!# %!&'(#Beveragae Air 2 236 2 323)*
User Manual for WTRF Refrigerator FreezerBeverage AirCLEANING AND MAINTENANCECleaning Schedule:CabinetCondenser coilGasketsDaily wipe downQuarterly cleaningPeriodicRoutine maintenanceWeekly interiorAnnuallyDaily Exterior CleaningIt is much easier to clean on a regular basis than to have to remove stains once they have built up.1.Wash with a clean sponge and a mild detergent thatdoes not contain chlorine.4. Polish with a soft cloth, wiping with the grain.5. Wipe weekly with stainless steel cleaner.2. Rinse with clean water.3. Dry with a soft cloth.Weekly Interior Cleaning1.Remove all food, food related items, and shelves.5. Rinse with clean water and allow to air dry2. Disconnect power to the cabinet at the main powersupply circuit breaker6. Re-install the shelves.7.3. Remove loose food particles from interior floors,walls, and ceiling4. Scrub all interior surfaces and drawer gaskets with awarm (100o-120oF) detergent solutionand a soft nylon bristle brushRestore power to the cabinet by resetting main powersupply circuit breaker8. Return food to the cabinet when temperatureindicator displays safe food temperatureGaskets1.Visually inspect the door gaskets for a tight seal onall four sides. Inspect for any type of damage such asrips, tears, stiffness, or cracks.2.If any such condition exists, the magnet will not sealand the gasket will need replaced.3. Cleaning the gasket requires the use of mild dishdetergent and warm water.4. Next, thoroughly rinse and dry the gasket.24Beverage AirRev. 07/22
User Manual for WTRF Refrigerator FreezerBeveragae AirDRAWER CLEANING AND MAINTENANCEDrawer models are shipped with the drawers already installed in the cabinets. Drawers are designed with slides whichhave locking mechanisms to prevent drawers from coming off cabinets during normal opening and closing operations.See illustration below:Drawers and slides can be removed from a cabinet for cleaning purposes. To remove a drawer from a cabinet follow theseinstructions:1.Open the drawer to full extension2. Push the white locking tabs forward on both sides of the drawer3. Press down the back of the tabs4. Slide the drawer out of the cabinet5. To remove the sliding member (Middle slide), press the metal tab up and slide it 6 - To reinstall the sliding member,press the metal tab up and slide it in6. To reinstall drawer, push the locking tab forward and press the back of the tab down 8 - Align the drawer slidemembers and moving slide members7.Slide the drawer in and lock the slide by pushing the front of the locking tab down and inRev. 07/22Beverage Air25
User Manual for WTRF Refrigerator FreezerBeverage AirCONDENSER CLEANINGKeeping the condenser coil clean is critical to efficientoperation.The condenser coil is located behind the front or reargrille of the cabinet. It should be inspected once a monthand cleaned as required. Vacuum clean all surfaces of thecondenser. Make sure no fins are bent or damaged in theprocess. If there are bent fins, carefully straighten themso that air can flow through the coils. Failure to keepthe condenser coil clean will lead to poor performance,excessive power consumption and compressor failureand may r
Phone: (888) 845-9800 Fax: (800) 253-5168 Web: beverage-air.com 809-172A 07/19/2022 SEE BACK COVER FOR WARRANTY REGISTRATION. User Manual for WTRF Refrigerator Freezer Beverage Air . serial number and the date of installation here for future reference. The model and serial numbers are on the unit's serial number dataplate, which is .
