Transcription
TheTru-Fit Series from CNIReplacement ChassisPackaged TerminalAir Conditioners/Heat PumpsDimensional and Engineering Data SpecificationsTru-Fit Replacement for Nesbitt Modular RoommateTru-Fit Replacement forNesbitt Roommate PKGTru-Fit Replacement forSinger/McQuay Series S,RS, EATru-Fit Replacement forAAF Series 16WWW.COMITALENATIONAL.COMComitale National, Inc.1683 B Winchester Road Bensalem, PA 19020215- 244-9650 FAX 215-244-9679 email: sales@comitalenational.comTo view our complete line of products visit - www.comitalenational.comFamily owned and operated for three generations.
Comparing theCNI Tru-Fit chassisagainst the Competition1.All CNI chassis are provided with a hot gas bypass valve. This gives the product an addedsafety feature against freeze ups on the evaporator coil due to low ambient or a cloggedfilter. The competition does not provide this feature.2.All CNI refrigeration tubing is specially designed to eliminate noise transmissionthroughsheet metal. The competition does not, allowing higher noise level.3.All CNI water holding pans are fully protected with a mastic coating which repels water. Thecompetition does not, which shortens the life of the product from corrosion.4.All wires in the CNI control box are fully insulated. This ensures of an unsurpassed amountof safety against electrical shorting. The competition uses exposed electrical terminals.5.All CNI sheet metal is of 18 gauge galvanized zinc plated steel. The base pan is 16 gaugegalvanized. The competition uses lighter gauge steel to save money.6.All CNI chassis are provided with a low limiting thermostat. This gives the product an addedsafety against freeze ups on the evaporator coil due to low ambient or a clogged filter. Thecompetition does not provide this feature.7.All CNI chassis use Sporlan thermostatic expansion valves. This allows the evaporator coil tobe full under all load conditions. The competition uses a cheaper automatic expansion valve.This starves the evaporator at high load conditions and overfeeds it at low load conditions.8.All CNI chassis use what is known as Blow-Through design, which sends air through the coil.The competition uses a draw through method, which causes recirculation ofcondenser hot air and results in unit premature failure. This method also causes the unit todraw higher amperage which costs more money to operate and maintain.Also when using the propeller condenser fan method - ice will lock up thecondenser fan preventing operation of the unit in the winter.As you can see from the above list, CNI chassis provide you with standardfeatures that the competition considers specials or are unable to provide.Our products are far superior in construction and quality.CNI reserves the right to make changes in design and construction at any time without notice.
Comitale National, Inc.Family owned and operated for three generations.CONTENTSProduct Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4NEMA Mating Power Receptacles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5Integral Style Replacement ChassisCCCO Series (Replaces Nesbitt and MSI Challenger) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6CAF16O Series (Replaces American Air Filter 16, WY, YY, and ENERSAVER ,Singer and McQuay ENH, ENR, PNES1, PNHS1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6CTPIO Series (Replaces T.P.I. , Cool Heat RM, Climate Master 702, 703, 704, Beacon Morris ,Embassy Weather Twin , Ice Cap RSK, Kapsis , Ra-Matic and ZoneAire RM & SC) . . . . . . . . . . . . . . . . . . . . . . 6CFOO Series (Replaces Fedders Unizone, Climatrol , Climazone UVK, UVW, UVY and Airtemp Tempzone) . . . . 7CA45O Series (Replaces American Standard , Singer SG45, 45, Carteret 45and McQuay PNES2 and PNHS2) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7CRSO Series (Replaces Singer and McQuay S, ES, RS, MQT, PMES and PMRS) . . . . . . . . . . . . . . . . . . . . . . . . . 7CEAFO Series (Replaces Singer and McQuay EA-F, MEA, MQA, PMES). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8CSEAO/CSHAO Series (Replaces Heil Quaker SEA and SHA) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8CEALO Series (Replaces Singer and McQuay EA-A/L.H., MEA, MQA, and PMES) . . . . . . . . . . . . . . . . . . . . . . . . . 8CEARO Series (Replaces Singer and McQuay EA-A/R.H., MEA, MQA, and PMES). . . . . . . . . . . . . . . . . . . . . . . . . 9CWRBO Series (Replaces Westinghouse and Coastal RB) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9Integral Unit Models 07-18 Data Sheet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Component Style ReplacementsCMRO Series (Replaces Nesbitt and MSI Modular Roomate). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11CRPO Series (Replaces Nesbitt and MSI Roomate PKG) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11CNIIIO Series (Replaces Dunham Bush Newport, III, IV, V) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12CAF25O Series (Replaces American Air Filter , McQuay 25, GXY, and XY, and Nelsonaire 25 . . . . . . . . . . . . . . 12CA41O Series (Replaces American Standard Series 41, McQuay , and Remotaire ) . . . . . . . . . . . . . . . . . . . . . . . 12CRJO Series (Replaces Remington , Singer and McQuay J-EJ (EJB, JB, EJC, JC, MQC, MEJ,PMEJ, and PMEH)) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13CRKO Series {07-22} (Replaces Remington /Singer and McQuay K, EK, RK, MEK,MHK, MQP, PKES, and PKHS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13Component Unit Models 07-18 Data Sheet. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14Component Unit CRKO 22 Data Sheet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16Nesbitt TP Condensing Section. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17CNI PC-PH 7000-24000 BTUH PTAC/HP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18CNI ULTRAMATE Modular Component PTAC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19Consult factory for products not listed.Comitale National Inc.3
Product Code Sheet(Z in any box Special)CRKO09C4-D10RSDesign SequenceRS Rotary CompressorAS Reciprocating CompressorAZ SpecialProduct CodeK-ReplacementChassis TypeH HeatpumpC Cooling onlyControl Options0 None1 Night Set Back2 Remote Switching withNight Setback3 Fan Cycle Switch (Heating Mode)4 Auxiliary - Permanent Power*Voltage needs to be determined forprimary (Hydronic Heat Only)Z Consult FactoryNominal Size07 - 7000 BTUH09 - 9000 BTUH12 - 12000 BTUH15 - 15000 BTUH18 - 18000 BTUH22 - 22000 BTUHElectrical Service3 115/60/14 208/230/60/15 277/60/1Thermostat Nominal Size0 Cooling only, Component Style Chassis1 Unit Mounted Manual Changeover2 Wall Mounted, Manual Changeover*3 Unit Mounted Automatic Changeover*4 Wall Mounted, Automatic Changeover5 Non-Programmable Wireless6 Programmable Wireless*Not available on HP chassisKHeat Source0 Cooling onlyD Hydronic HeatA 2.5/3.0 KWB 3.3/4.0 KW*C 4.3/5.3 KW**E 5.3/5.8 KW*Not available sizes 07 and 09**Available size 22 onlyZ SpecialsOutlined in Spec.The sample unit nomenclature above indicates a CNI Cooling Chassis for replacement of a McQuay Type "K";9000 BTUH, 208-230/60/1, Hydronic Heat, Unit Mounted, Manual Changeover, No Control Options, StandardDesign and Rotary Compressor.Comitale National Inc.4
NE M AR ECEPTACLESMating Power Receptacles for CNI Integral Style UnitsIntegral Style - A complete, self-contained chassis consisting of motor assembly, heating andcooling system, along with a control box.NEMA 5-15R (115V)Service: 15 AmpVoltage: 115VNEMA 6-15R (250V)Service: 15 AmpVoltage: 208/230V139-0100139-0011NEMA 5-20R (115V)NEMA 6-20R (250V)Service: 20 AmpVoltage: 115VService: 20 AmpVoltage: 208/230V139-0101139-0018NEMA 6-30R (250V)NEMA 7-20R (277V)WService: 30 AmpVoltage: 208/230V139-0010Service: 20 AmpVoltage: 277V139-0012Comitale National Inc.5
SECTION1Integral Style - A complete, self-contained chassis consisting of motor assembly, heating andcooling system, along with a control box.TYPE CCCO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Nesbitt andMSI Challenger Cooling andHeatpump Chassis.20 1/2CONTROL BOX4 1/2 x 2310 1/2DISCHARGE AREA1435 3/415 1/25Select NEMA cord from page 5.TYPE CAF16O SERIESReplacement Packaged Terminal Air ConditionersReplaces Original American AirFilter Type 16, WY, YY, andENERSAVER, Singer andMcQuay Type ENH, ENR,PNES1, PNHS1 Cooling andHeatpump Chassis.DISCHARGE AREA19514 1/214 7/834 1/2Select NEMA cord from page 5.TYPE CTPIO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original T.P.I. ,Cool Heat Type RM, ClimateMaster 702, 703,and 704 Type,Embassy Weather Twin ,Ice Cap RSK Type, Kapsis ,Ra-Matic , Beacon Morris andZoneAire Corp. RM and SCType Cooling and HeatpumpChassis.CONTROL BOX43/428DISCHARGE AREA11581836Select NEMA cord from page 5.Comitale National Inc.6
SECTION1TYPE CFOO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Fedders Unizone, Climatrol , Climazone UVK, UVW, UVY and Airtemp Tempzone Cooling andHeatpump Chassis.DISCHARGE AREA28 1/4CONTROL BOX5 1/215 3/814 1/218 1/247Select NEMA cord from page 5.TYPE CA45O SERIESReplacement Packaged Terminal Air ConditionersDISCHARGE AREA19Replaces Original AmericanStandard , Singer Type SG45and 45, Carteret Type 45,McQuay Type PNES2 andPNHS2 Cooling and HeatpumpChassis.514 1/214 7/834 1/2Select NEMA cord from page 5.TYPE CRSO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Singer andMcQuay Type S, ES, RS, MQTPMES and PMRS Cooling andHeatpump Chassis.CONTROL BOX1543 7/814 x 42 5/881/2Note advise factory:Coil Placement - High or LowExtendaire or Ducted Application.1018 1/2Select NEMA cord from page 5.Comitale National Inc.7
SECTION1TYPE CEAFO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Singer andMcQuay Type EA-F, MEA, MQAand PMES Cooling and HeatpumpChassis.CONTROL BOX1514 x 42 5/8Note advise factory:Extendaire or Ducted Application.81/243 7/81018 1/2Select NEMA cord from page 5.TYPE CSEAO/CSHAO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Heil Quaker Type SEA and SHA Cooling andHeatpump Chassis.CONTROL BOX43/428DISCHARGE AREA1158Select NEMA cord from page 5.3618TYPE CEALO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Singer andMcQuay Type EA-A/L.H., MEA,MQA and PMES Cooling andHeatpump Chassis.DISCHARGE AREA4 x 21Note advise factory:Extendaire or Ducted Application.15 1/215 X 4481/244Select NEMA cord from page 5.1745Comitale National Inc.8
SECTION1TYPE CEARO SERIESReplacement Packaged Terminal Air Conditioners19 3/8Replaces Original Singer andMcQuay EA - A/R.H., MEA,MQA and PMES Cooling andHeatpump Chassis.5 x 24DISCHARGE AREA15 7/814 5/88 3/4AUX.ELEC.BOXFUSEBOX15 1/8Note advise factory:Extendaire or Ducted Application.43 3/844 1/417 1/2Select NEMA cord from page 5.TYPE CWRBO SERIESReplacement Packaged Terminal Air Conditioners3 7/8 x 29Replaces Original Westinghouse and Coastal Products Type RBCooling and Heatpump Chassis.CONTROL BOXDISCHARGE AREA141/2151/4381/471/2201/8Call CNI for more details and competitive pricing!Ask about our Quick Shipment Program.Think CNI for all of your replacement HVAC parts needs.Select NEMA cord from page 5.A lower cost alternative to all seasoncomfort conditioning.More Reliability .Less Maintenance.Simpler Installation .Higher Efficiency.A Quieter Solution .A Tru-FitQuality and Comfort for manyyears to come!Look to CNI for all of your Water Source Heat Pump needs, replacement,retrofit, or for new construction. Consult factory for additional information.Comitale National Inc.9
SECTIONDATA SHEET1 INTEGRAL STYLEModel NumbersNominal CapacityVoltage115077000208 230 277115099000208 230277 1151212000208 2302771515000208 230 2771818000208 230 277Cooling - Heat Pump and Cooling Only ChassisCOOLING (HI-FAN SPEED)1Total Capacity (BTUH)Sensible Capacity (BTUH)7300 7300 7300 7300 9000 9000 9000 9000 11800 11800 11800 11800 14939 14939 14939 17361 17361 173616320 6320 6440 6440 7151 7151 7271 7271 8586 8586 8710 8710 10963 11083 11083 12022 12142 12142ELECTRICAL DATAFull Load AmpsLocked Rotor AmpsFull Load KWEER (BTUH/Watt)Power Factor %6.8 3.6 3.339.2 16.6 16.6.74 .74 .749.8 9.8 9.898.0 98.0 97.02.7 8.7 4.617.1 48.3 31.0.74 .93 .939.8 9.7 9.798.0 90.7 90.74.1 3.9 11.4 6.4 5.8 4.8 7.6 6.9 6.0 9.2 8.5 7.431.0 22.9 54.0 34.2 34.2 30.0 40.0 40.0 35.0 48.2 48.2 44.0.93 .93 1.24 1.24 1.24 1.24 1.57 1.57 1.57 1.89 1.89 1.899.7 9.7 9.4 9.4 9.4 9.4 9.5 9.5 9.5 9.1 9.1 9.190.6 92.6 98.0 99.0 98.9 99.0 98.6 97.5 97.7 92.7 92.3 92.2Heating - Reverse Cycle Heat Pump OnlyHEATING (HI-FAN SPEED)Capacity (BTUH)8400 8400 8400 8400 10200 10200 10200 10200 13300 13300 13300 13300 15500 15500 15500 18100 18100 18100ELECTRICAL DATAFull Load AmpsLocked Rotor AmpsFull Load KWCOP (Coefficient of Performance)Power Factor %N/AN/AN/AN/AN/A3.4 3.1 2.616.6 16.6 17.1.68 .68 .683.6 3.6 3.695.7 95.3 94.4N/AN/AN/AN/AN/A5.0 4.6 3.831.0 31.0 22.9.92 .92 .923.2 3.2 3.288.5 87.1 87.4N/A 5.9 5.4N/A 34.2 34.2N/A 1.2 1.2N/A 3.2 3.2N/A 97.8 96.64.5 6.6 6.0 5.0 7.7 7.0 5.830.0 40.0 40.0 35.0 48.2 48.2 44.01.2 1.35 1.35 1.35 1.48 1.48 1.483.2 3.3 3.3 3.3 3.5 3.5 3.596.3 98.3 97.8 97.5 92.4 91.9 92.1Hydronic HeatHEATING (HI-FAN SPEED)Hot Water (BTUH)2Steam 8,90014,30018,900Recommended Overcurrent Protection - 19.6 14.4 —— 19.6 14.4 —— 19.6 14.4 —— 14.4 —— 14.4 ———— 15.3 12.5 —— 15.3 12.5 —— 15.3 12.5 — 15.3 12.5 — 15.3 12.5— 18.3 ——— 18.3 ——— 18.3 —— 18.3 —— 18.3 ———— 19.6 16.1 —— 19.6 16.1 —— 19.6 16.1 — 19.6 16.1 — 19.6 16.1————————— 23.1 —— 23.1 —— 23.1 ———————————— 25.2 20.8 — 25.2 20.8 — 25.2 20.8Recommended Overcurrent Protection - AmperesCOOLING/HEAT PUMP CHASSISW/O Auxiliary HeatingWith Auxiliary Heating2.5 KW to 3.0 KW3.3 KW to 4.0 KW4.3 KW to 5.3 KWSteam or Hot 02530152025351520253015202530202025352020253015Fan Motor DataCFM-COOLING AND HEATINGHigh SpeedLow SpeedVentilationMotor 50851/4180F DB/67F WB air entering evaporator; 95F DB/75F WB air entering condenser per ARI Std. 310-70. 2 200F EWT/180F LWT at 2 GPM 70F EAT. 3 2 PSI 70F EAT saturated steam.CNI reserves the right to modify specifications without prior notice in its efforts to improve product quality. Wattage, Amperage & EER is based on compressor and condensing fan motor data.10
SECTION2Component Style - Consisting of separate; cooling chassis, heating section, evaporative motorboard assembly and control box.TYPE CMRO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Nesbitt andMSI Modular RoommateCooling and Heatpump Chassis.DISCHARGE AREANote advise factory:14 1/23034MODEL - 07, 09,12Front panel slope or flat.Wall sleeve high or low intake.11MODEL - 15,1817 1/2TYPE CRPO SERIESReplacement Packaged Terminal Air Conditioners18Replaces Original Nesbitt andMSI Roommate PKG Coolingand Heatpump Chassis.17143419Call CNI for more details and competitive pricing!Ask about our Quick Shipment Program.Think CNI for all of your replacement HVAC parts needs.A lower cost alternative to all seasoncomfort conditioning.More Reliability .Less Maintenance.Simpler Installation .Higher Efficiency.A Quieter Solution .A Tru-FitQuality and Comfort for manyyears to come!Look to CNI for all of your Water Source Heat Pump needs, replacement,retrofit, or for new construction. Consult factory for additional information.Comitale National Inc.11
SECTION2TYPE CNIIIO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original DunhamBush Newport, III, IV, and VCooling and Heatpump Chassis.41 1/231/211/25 1/2 x 19 1/213 5/8113 1/2TYPE CAF25O SERIESReplacement Packaged Terminal Air ConditionersReplaces Original American AirFilter , McQuay Type 25, GXYand XY, Nelsonaire Type 25Cooling and Heatpump Chassis.363417 3/814 3/83 1/814 5/817 3/818 5/814 1/41417TYPE CA41O SERIESReplacement Packaged Terminal Air ConditionersReplaces Original AmericanStandard Series 41, McQuay and Remotaire Cooling andHeatpump Chassis.12 5/817 1/414 1/4 X 3435 5/817Comitale National Inc.12
SECTION2TYPE CRJO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Remington ,Singer and McQuay Type J-EJ,EJB, JB, EJC, JC, MQC, MEJ,PMEJ, PMEH Cooling andHeatpump Chassis.91/2””/8525*Not Available in size 18000 BTU12 27/32”/8203283/”64”TYPE CRKO SERIESReplacement Packaged Terminal Air ConditionersReplaces Original Remington /Singer and McQuay Type K,EK, RK, MEK, MHK, MQP, PKESand PKHS Cooling andHeatpump Chassis.{07-18}19 1/4147 7/817 1/23435 1/2{07-22}Comitale National Inc.13
SECTION2 - COMPONENT STYLEModel NumbersNominal CapacityVoltage115077000208 230 277115099000208 230DATA SHEET277 1151212000208 2302771515000208 230 2771818000208 230 277Cooling - Heat Pump and Cooling Only ChassisCOOLING (HI-FAN SPEED)1Total Capacity (BTUH)Sensible Capacity (BTUH)7300 7300 7300 7300 9000 9000 9000 9000 11800 11800 11800 11800 14939 14939 14939 17361 17361 173616320 6320 6440 6440 7151 7151 7271 7271 8586 8586 8710 8710 10963 11083 11083 12022 12142 12142ELECTRICAL DATAFull Load AmpsLocked Rotor AmpsWattsEER (BTUH/Watt)*Power Factor 19.594.06.035.015909.593.59.248.219139.195.28.5 7.448.2 44.01955 19619.1 9.193.0 93.0Heating - Reverse Cycle Heat Pump OnlyHEATING (HI-FAN SPEED)Capacity (BTUH)7000 7000 7100 7100 8500 8500 8700 8700 11400 11400 11600 11600 1430014500 14500 17200 17500 17500ELECTRICAL DATAFull Load AmpsLocked Rotor AmpsFull Load KWCOP (Coefficient of Performance)Power Factor %N/A 4.5N/A 16.6N/A .85N/A 2.9N/A 90.24.2 3.6 N/A16.6 17.1 N/A.85 .85 N/A3.0 3.0 N/A86.5 84.9 N/A5.9 5.5 4.523.8 23.8 22.2.96 .96 .962.8 2.9 2.992.4 89.3 89.9N/AN/AN/AN/AN/A7.3 6.9 5.8 8.7 8.0 6.7 10.6 9.8 8.134.2 34.2 30.0 40.0 40.0 35.0 48.2 48.2 44.01.35 1.35 1.35 1.5 1.5 1.5 1.7 1.7 1.72.8 2.9 2.9 2.9 3.0 3.0 2.8 2.9 2.994.7 90.4 90.1 95.7 94.0 93.5 95.2 93.0 93.0Hydronic HeatHEATING (HI-FAN SPEED)Hot Water (BTUH)2Steam 9,40018,75019,400Recommended Overcurrent Protection - .3——230—3.0—4.0—5.3277— 19.6 13.3—— 14.4—— 17.34.0 —————5.3 ———— 19.6 13.3 —— 19.6 13.3 ——12.6 —— 14.4 12.6 —— 14.4 12.6 ———— 17.3 ——— 17.3 ——18.8 16.4 —— 18.8 16.4 —— 18.8 16.4——————— 22.1 —————————— 24.4 21.513.3 —— 13.3 ——14.4 12.6 — 14.4 12.617.3 —— 17.3 ——— 18.8 16.4 — 18.8 16.422.1 —— 22.1 ——— 24.4 21.5 — 24.4 21.5Recommended Overcurrent Protection - AmperesCOOLING/HEAT PUMP CHASSISW/O Auxiliary HeatingWith Auxiliary Heating2.5 KW to 3.0 KW3.3 KW to 4.0 KW4.3 KW to 5.3 KWSteam or Hot 02530152025351520253015202530202025352020253015Fan Motor DataCFM-COOLING AND HEATINGHigh SpeedLow SpeedVentilationIndoor Motor HPOutdoor Motor F DB/67F WB air entering evaporator; 95F DB/75F WB air entering condenser per ARI Std. 310-70. 2 200F EWT/180F LWT at 2 GPM 70F EAT.CNI reserves the right to modify specifications without prior notice in its efforts to improve product quality.* Wattage, Amperage & EER is based on compressor and condensing fan motor data.14435375851/201/432435375851/201/4PSI 70F EAT saturated steam.
CRKO SERIES 22,000 ENGINEERING DATA22Model G CHASSISCOOLING (HI-FAN SPEED)1Total Capacity (BTUH)Sensible CapacityELECTRICAL DATAFull Load AmpsLocked Rotor AmpsWattsEER (BTUH/Watt)Power Factor 9.956.022779.998.08.456.022269.997.1HEATING CAPACITYHEATING (HI-FAN SPEED)Capacity (BTUH)23533 23533 23533ELECTRICAL DATAFull Load Amps10.39.37.8Locked Rotor Amps56.056.052.0Full Load KW2.152.152.15COP (Coefficient of Performance)3.23.23.2Power Factor %99.098.097.1HYDRONIC HEATHEATING (HI-FAN SPEED)Hot Water (BTUH)2Steam (BTUH)321,90023,800ELECTRIC HEAT VER CURRENT PROTECTION AMPERSCOOLING/HEAT PUMP CHASSISW/O Auxiliary HeatingWith Auxiliary Heating2.5 KW to 3.0 KW3.3 KW to 4.0 KW4.3 KW to 5.3 KW5.3 KW to 5.8 KWSteam or Hot WaterFAN MOTOR DATACFM-COOLING AND HEATINGHigh SpeedLow SpeedVentilationMotor HP575475851/315
Additional Manufactured Parts forTru-Fit Replacement ChassisMOTOR BOARD ASSEMBLIESCONTROL BOXESHYDRONIC COILS &VALVE ASSEMBLIESELECTRIC ELEMENT ASSEMBLIESPLENUM ASSEMBLIESConsists of: Evaporator Motorboard Control Box Heating SectionHot Water, Steam or ElectricNote: Complete Room Cabinet Assemblies, Wall Sleeves, Outdoor Louvers, Room Cabinet andFront Panels, Kick Plate or Sub Bases are available for most Tru-Fit Chassis Product Offerings.Comitale National Inc.16
SECTION3CNI Replacement for the Nesbitt TP Condensing SectionsCNI provides condensing units for replacement orupdate of equipment originally installed for selfcontained Unit Ventilators. CNI manufacturescondensing unit sections for the Nesbitt SyncretizerPKG and Split System Unit Ventilators. The originalNesbitt TP condensing unit was engineeredspecifically for the class room application andincorporated unmatched design and safety featuresrequired for this application. CNI todaymanufactures its products to these same highstandards of excellence.TP Condensing Unit Engineering DataUNIT NSIONVALVEFILTER DRIERNominal Cooling CapacityLIQUID LINEPower Supply3.5 Ton208/230-60Hz1ph208/230-60Hz 3ph208/480-60Hz 3phDISCHARGE LINESUCTION LINEUNIT VENTILATORHEAT PANSIONVALVE BULBCONDENSERCOMPRESSORLIQUID LINETotal Running Amps208/230-60Hz 1ph208/230-60Hz 3ph208/480-60Hz 3ph29.0**19.0**10.5**Starting Amps - Compressor*208/230-60Hz 1ph208/230-60Hz 3ph208/480-60Hz 3ph147.9120.960.2Maximum Wire Size(Maximum Fuse Delay Type)208/230-60Hz 1ph208/230-60Hz 3ph208/480-60Hz 3ph25 1/41948No. AWG Fuse Size6408301215Fan MotorHorse PowerFull Load Amps1/35.5RefrigerantR22* Based on 95oF condensing temperature 80oF DB-67oF WB and80oF maximum air over fuses and nominal voltage.** Includes fans, compressor and accessories.Comitale National Inc.17
ThePC-PHSeries Madein USAFor newconstruction, planand specification,as well asdesign-build.A Complete Packaged Terminal Air Conditioner/Heat Pump from 7000 BTUH up to 24,000 BTUHHow many of these benefits do you want in your packagedterminal air conditioner/heat pump:Low Energy Consumption condenser coils-lanced fin rifle tubing, largersurface area higher EER’s, longer compressor life low limiting thermostatInstitutional Quality constructed of 18 gauge sheet metal minimum fully insulated terminal & electrical componentsLow Installed Cost the sleeve (42” x 16”) matches the standardbrick& block module outdoor louvers are shipped pre-installed onsleeve the slide-in chassis plugs into a special outletprovided with the sleeve a flat or slope top front enclosure, completewith discharge grilleLow Noise Level a true 2 speed motor lower DB levels discharge and suction line mufflerEasy Installation 2 major components, wall sleeve and chassisFour Season Use DX Cooling, electric, hydronic or steam heatMinimum Maintenance filters readily available behind front panelWeatherproof clear anodized outdoor louverDetails & DimensionsASLEEVEBSLEEVEACCESS DOORLOCATEDONLEFT SIDE ONMODEL 22/24CD3/4 LOUVERWall Opening GuideModelABCDESleeveOnlyWith SleeveExtensionWith LouverFrame7 thru 18 MBH42165 3 4165 5 842 1 4 x 16 1 442 7 16 x 16 1 242 11 16 x 16 3 422 thru 24 MBH5020618 3 8650 1 4 x 20 1 450 7 16 x 20 1 250 11 16 x 20 3 42DComitale National Inc.18E
Comitale National, Inc.Family owned and operated for three generations.The Tru-Fit Seriesreplacement chassis--The answer to all your thru the wall needs. Adirondack-Aire Ice Cap American Air Filter Type 16,WY and YY Kapsis Airtemp American Air Filter Type 25,GXY and XY American Standard Type 41, 45and SG45 Applied Comfort Beacon Morris Carteret Type 45 Climate Master 702, 703 and 704 Climatrol Islandaire Lennox M.S.I. Nelsonaire Type 25 McQuay /Remington /Singer TypesK, EK, RK, EA-A, EA-F, S, ES, RS, ENH,ENR, MEA, MEK, MHK, MQA, MQP,MQT, PNES1, PNHS1, PNES2, PNHS2,PMES, PMRS, PKES, PKHS, J-EJ, EJB,JB, EJC, JC, MQC, MEJ, PMEJ andPMEH. Coastal Products RB Nesbitt Challenger, Mod Roommateand Roommate PKG Cool Heat Type RM RetroAire Embassy Weather Twin T.P.I. Heil Quaker Type SEA and SHA ZoneAire NewYorker Climazone UVK, UVW and UVY Ra-Matic Cold Point, Corp. Dunham Bush Newport, III, IV and V Simon-Aire, Inc. Fedders Unizone Westinghouse RB Ice Air Available in Efficient Heat Pump Configuration.*Note CNI can also replace Amana , Carrier 52 Series, Fedders FPTH and FPTA,Friedrich PE and PH, and General Electric AZ Series.*Consult factory on the above units.Consult factory for products not listed.
MakeYour First Choice for HVACEquipment and Replacement PartsTru-Source O.E.M. Replacement PartsIn stock for immediate deliveryFrom unit ventilators to rooftop systems American Air Filter American Standard Climatrol Dunham Bush Fedders Unizone Ice Cap Islandaire Kapsis Lennox ThePC-PHSeries MSI McQuay Nesbitt Remington RetroAire Singer T.P.I. Westinghouse For new construction,plan and specification,as well as design-build.A complete packagedterminal AirConditioner/Heat PumpSizes ranging from 7,000BTUH through 24,000 BTUHBuilding types include, but are not limited to: Nursing Homes Convalescent Centers Hospitals Hotels/Motels Office Buildings Schools/UniversitiesAir Conditioner/Heat Pump ULTRAMATEA MODULAR COMPONENT AIR CONDITIONERFor New Construction and ReplacementsA low-cost alternative to all-season comfort conditioning. More reliability Easy installation Quiet operation Energy EfficientAn ideal component type system application for: Nursing Homes Schools/Universities Hospitals Office Buildings Convalescent Centers Hotels/MotelsComitale National, Inc.1683 B Winchester Road Bensalem, PA 19020 215- 244-9650 FAX 215-244-9679Visit our website - www.comitalenational.com email: sales@comitalenational.comRC Pub. TF/TP, Issue 10M 3/16 2016 Comitale National, Inc.
TheTru-Fit Series from CNI Replacement Chassis Packaged Terminal Air Conditioners/Heat Pumps Comitale National, Inc. 1683 B Winchester Road Bensalem, PA 19020 215-244-9650 FAX 215-244-9679 email: sales@comitalenational.com
