Transcription
MONITORS AND CONTROLSThe Astro II GPS Speed Sensors are a direct replacement for magnetic wheel speedsensors or radars and can interface to most brands of monitors and controllers.The magnetic mount bracket is standard and allows for quick installation and easy transferfrom one vehicle to another.Not affected by crop canopies or adverse ground conditions.ASTRO II FOR MICRO-TRAKPART NO.01410DESCRIPTIONAstro II for Micro-Track ConsolesLIST PRICE 558.89ASTRO II FOR RAVEN CONSOLESPART NO.01415DESCRIPTIONAstro II for Raven ConsolesPART TIONAstro II for Micro-Trak MT3000/5000Astro II for Micro-Trak Old Style Calc-An-Acre 84CAstro II for Dickey-John 4 pin AMPAstro II for Dickey-John PackardAstro II for Magnavox / PhillipsAstro II for TeeJet 855 Sprayer ControlAstro II for Hiniker ControllersAstro II for Hardi SprayersLIST PRICE 558.89LIST PRICE 558.89 558.89 558.89 558.89 558.89 558.89 613.21 558.89Astro Series GPS Speed SensorInstructionsASTRO5 (cont.)operation:The ASTRO 5 is a non stock item, lead time will applyLike all GPS receivers, the Astro requires time to acquire the satellites and stabilize before it begins to output a speed signal. The Astro includes twored lights on the interface module, (see Illustration) to indicate status of power to the Astro and the status of the GPS receiver:ASTRO 5 GPS SPEED SENSORSDESCRIPTIONAstro II for TeeJet ConsolesAstro Series GPS Speed SensorInstructions (cont.)Micro-Trak Base ProductsP/N# 01410 / 01425nac 5 minutesthe Astro to acquire a signal.Hook up Raven 440/460P/N# 01415 / 01430Micro-Trak MT-3000P/N# 01411 / 01426GPS StatusPower OnConnectto groundPower OnHook up HinikerTo SOLID orange wire(aux. power)on Raven harness(Do NOT connect toorange wire with white stripe)SPRAYERSPECIALTIESExtended Warranty OptionSETo 12 VDCSourceAGPS StatusHook up HinikerP/N# 01420 / 01435PLETo MT-3000Controllerak MT-3000411 / 01426To speed input onRaven harnessECPRIC ATAA P P LY D I S CIt’s simple! Just complete the registration for this productONLINE at www.micro-trak.com and we’ll extend your warrantyfor up to three years*, at no additional charge.Registration information is for internal use only.Hook up Raven 440/460NOTE: Set Raven Console to SP2 - Radar Speed SensorII SPEED CALNUMBERSP/N#includes01420 / 01435The Astro2Toredstatus lightsP/N# 01415 /ASTRO01430 12 VDCSourceConsoleTypeAstro IIon the interface module:To MT-3000ControllerLOGRed SignalWhite PowerBlack Grounde initial hookup or your Astro has beenST allow for a minimum of 5 minutes forLIST PRICE 751.86 751.86Red SignalWhite Power 751.86Black Ground 751.86 751.86 751.86 751.86 751.86 751.86To 12 VDCSource 801.88 751.86NTPART NO.01417PART NO. DESCRIPTIONTypical startup times:Micro-Trak Base Productssearchto acquire 5 minutesAstro5almanacfor Micro-Trak01425 SkyP/N# 01410 / 01425Cold start 2.5 minutes Warmstart 30secondsAstro 5 for Micro-Trak MT3000/500001426IMPORTANT NOTE: If this is the initial hookup or your Astro has beenor more youfor a minimum of 5OldminutesStylefor01427 offtheforAstro4 daysAstro5 MUSTfor allowMicro-TrakCalc-An-Acre 84Cacquire a signal.Astro SeriestoAstroGPS5SpeedSensor 4 pin AMP01428for roP/N#5 01411for Dickey-JohnPackard01429LIST PRICEoperation:/ 01426Like all GPS receivers, the Astro requires time to acquire the satellites 01430and stabilize before it begins Astroto output a speedsignal.The Astro includes two5forRavenGPS Status 558.89red lights on the interface module, (see Illustration) to indicate status of power to the Astro and the status of the GPS receiver: Power: turns on when power is applied to the unit01431Astro 5 for Magnavox / PhillipsPower On Valid GPS: blinks when the GPS receiver is working but has not yet acquired a satellite fix. Once a fix has been acquired, it will be on steadily. Ifthe GPS system fails, the light will turn off.Astro 5 for TeeJet 844 Sprayer Control01432Typical startup times:Hook up HinikerTo MT-3000Base ProductsControllerAstro5 for TeeJet 855 SprayerControl P/N# 01420 / 0143501433 Micro-Trak Sky search to acquire almanac 5 minutesP/N# 01410 / 01425 Cold start 2.5 minutes Warm start 30 seconds01435Astro 5 for Hiniker ControllersRed SignalIMPORTANT NOTE: If this is the initial hookup or your Astro has beenWhite PowerConnectAstro 5 for Hardi Sprayersoff for 4 days or more you MUST allow for a minimum of 5 minutes 01848forto groundBlack GroundLISTASTRO II FOR TEEJET CONSOLESPower: turns on when power is applied to the unitValid GPS: blinks when the GPS receiver is working but has not yet acquired a satellite fix. Once a fix has been acquired, it will be on steadily. Ifthe GPS system fails, the light will turn off.OU er is applied to the unitGPS receiver is working but has not yet acquired a satellite fix. Once a fix has been acquired, it will be on steadily. Ifght will turn off.SpeedCal* Some limitations apply. See warranty statement for details.P/N 50250 Rev D Copyright 2007 Micro-Trak Systems, Inc. Page 2Connectto groundRaven 440/4601415 / 01430ct tote stripe)ASTRO II FOR OTHER MONITORS AND CONTROLSMONITORS AND CONTROLSGPS SPEED SENSORrequires time to acquire the satellites and stabilize before it begins to output a speed signal. The Astro includes twoule, (see Illustration) to indicate status of power to the Astro and the status of the GPS receiver:e wirer)ness145Micro-Trak SodPro II, ProPlant II, ProSeed, GSC-1000, POWER: turns on when power is appliedMT-3405D,MT-NH3II, SprayMate II, Calc-An-Acre II,To speed inputonto the unit.Raven harnessFlowTrak II, MT-2405F II, MT3405F II, RoadMaster Valid GPS: blinks when the GPS receiverMT-NH3, SprayMate, MT-403/MT-400, Calc-An-Acre LR,To SOLID orange wireExtended Warranty Optionis working but has not yet acquired(aux. power)FlowTrak LR, MT-2405F,MT-3405F, SodPro, AutoTrol,It’s simple! Just complete the registration for this producton Raven harnesssatellites. Once a satellite fix has beenONLINE at www.micro-trak.com and we’ll extend your warrantyMT-9000for up to three years*, at no additional charge.To speed input onbeen achieved, it will be on steadily. IfRegistration information is for internal use only.Speed-O-MeterRaven harnessSP2 - Radar Speed Sensorthe GPS system fails, the light will NOTE:turnSet Raven Console toMT-3000/MT5000P/N 50250 Rev D Copyright 2007 Micro-Trak Systems, Inc. Page 2All RavenExtended Warranty Optionoff.(Do NOT connect toorange wire with white stripe)* Some limitations apply. See warranty statement for details.Typical Startup Times:It’s simple! Just complete the registration for this productONLINE at www.micro-trak.com and we’ll extend your warrantyfor up to three years*, at no additional charge.Registrationtoinformationis for internal almanacuse only. Sky searchacquire 5 minutessole to SP2 - Radar Speed Sensor Cold Start 2.5 minutesP/N 50250 Rev D Copyright 2007 Micro-Trak Systems, Inc. Page 2 WarmStart 30 seconds* Some limitations apply. See warranty statement for details.Calc-An-Acre 84C, FlowTrak 84C/FT96CMid-Tech ARC6000Dickey-John AMPTeeJet 844TeeJet 13014170141969101.807831.709946146923923*To use the Astro II with Sirus Consoles, the console needs to be changed from 5 volt to 12 volt. This is done during the programming of the console. 145Grimes, IA 800-351-1587 Gardner, KS 877-829-8502 Brimfield, IL 855-778-8500
Console TypeConnector TypeNTOULISTCONNECTOR TYPELOGTypical Startup TimesECPRIC ATASPRAYER sky search to acquire almanac - 5 minutes (Re-initialization) Cold start - 2.5 minutes (Known almanac - re-acquire position, time, and satellite data.SPECIALTIES Warm start - 30 seconds (Known almanac, position, and time data - re-acquireS E satelliteC data.AOutput Signal 50% duty cycle square wave proportional to vehicle speed selectable output rate - 46.56 or 10.1149 Hz/Mile/Hour Maximum speed output - 750 mphPLEMONITORS AND CONTROLSMONITORS AND CONTROLS146Astro series GPs speed sensorsA P P LY D I SPart NumberAstro IIAstro 5Micro-Trak Calc-An-Acre LR, Calc-An-Acre II, FlowTrak LR, FlowTrak II, GSC-1000, MT-NH3,MT-NH3 II, MT-403/MT-400, MT-2405F, MT-2405F II, MT-3405D, MT-3405F,MT-3405F II, MT-9000, PLC-10X, ProPlant II, RoadMaster, SodPro, SodPro II,Speed-O-Meter, SprayMate, SprayMate II, SprayMate Plus, WhirlwindMetri PackShroud3-Pin 558.89Micro-Trak MT-3000/MT-5000Weather PackShroud3-Pin 558.89Micro-Trak Calc-An-Acre 84C, FlowTrak 84C/FT96CRound2-PinMicro-Trak Trak-Record IIMetri Pack3-Pinw/ DB9 (GPS)Raven SCS 440, 460 etc.Conxall 3-PinMid-Tech ARC 6000AMP CPC4-Pin0141301428 558.89 751.86DICKEY-John Amp connectorAMP CPC4-Pin 558.89DICKEY-John Delphi connectorWeather PackShroud4-pin 558.89Tee-Jet 844 Sprayer ControlDeutsch DT3-Pin 558.89Tee-Jet 855 Sprayer ControlDeutsch CMP3-Pin0141901433 558.89 751.86Hiniker Computer Facts, Acre Commander, Spray CommanderITT-Cannon Sure-Seal 3-Pin 613.21Hardi Sprayers (sprayer input connection)AMP Superseal3-Pin0184701848 558.89 751.86Magnavox / Philips Radar ConnectionWeather PackShroud4-pin0141601431 558.89 751.86146Grimes, IA800-351-1587 Gardner, KS877-829-8502014100141101412 558.89—01415 558.8901413014140141701420 Brimfield, IL 855-778-850001425 751.8601426 751.8601427 751.8601437 751.8601430 751.8601428 751.8601429 751.8601432 751.8601435 801.88
MONITORS AND CONTROLSThe RateKing Plus is a single-channel automatic liquid rate controller for agriculture, grounds, and highwaymaintenance. It offers a dual display that provides the target application rate in one display and several options for thesecond display, including: Output Drive (STD or PWM), VRA info., Elapsed Hours, Area per Hour, Total Width, andSection Status. Available in 3, 5, and 7 section versions.RATEKING PLUS CONTROLLER KITSPART ng Plus 5 Section with FM750 GFN Flow Meter & 1” Servo (LESS Speed Sensor)RateKing Plus 5 Section with FM750 GFN Flow Meter & 1” Servo, Magnetic Wheel SensorRateKing Plus 5 Section with FM750 GFN Flow Meter & 1” Servo, Astro II GPS Speed SensorRateKing Plus 7 Section with FM750 GFN Flow Meter & 1” Servo (LESS Speed Sensor)RateKing Plus 7 Section with FM750 GFN Flow Meter & 1” Servo, Magnetic Wheel SensorRateKing Plus 7 Section with FM750 GFN Flow Meter & 1” Servo, Astro II GPS Speed SensorLIST PRICE 3,064.60 3,331.89 3,620.63 3,447.67 3,712.11 4,005.13MONITORS AND CONTROLS147RATEKING PLUS & RATEKING DUAL PLUSThe RateKing Dual Plus simultaneously controls the application of TWO products from one controller. Accomplishmore with one controller than ever before.Advanced FeaturesANTOULISTLOGEC Adjustable PWM minimum and maximum pulse widthPRIC ATASPRAYERto prevent motor stalling or over-pressure. VRA capable Selectable NH3 and Turf unitsSPECIALTIESSE NH3 compatibleA P P LY D I S C Optional flowmeter kits and control valve kits Compatible with the Astro series of GPS based speed sensors andradar ground speed sensorsPLE Three modes of channel operation - Normal, Injection, and Parallel,offer unparalleled flexibility in setup. Innovative Multifunction Outputs on each channel can be set to controlan On/Off valve for: Flow Trigger, Relief, Master, and Flush, & others Flow or Pressure based control Pressure monitoring PWM or Servo electrical control Can be used with EMD (Electric Motor Driver)RATEKING PLUS & RATEKING DUAL PLUS CUSTOMIZEDSelect from A, B, C and D to build custom systems.RateKing Dual Plus requires two flowmeters and two flow control devicesfor dual channel controlA - RATEKING PLUS CONSOLES WITH MAIN HARNESSPART NO.018780188101893DESCRIPTIONRateKing Plus 3 Section CustomizedRateKing Plus 5 Section CustomizedRateKing Plus 7 Section CustomizedLIST PRICE 2,046.88 2,046.88 2,425.66A - RATEKING DUAL PLUS CONSOLES WITH MAIN HARNESSPART NO. DESCRIPTIONLIST PRICE01909RateKing Dual Plus 3 Section Customized 3,494.8401899RateKing Dual Plus 5 Section Customized 3,494.8401910RateKing Dual Plus 7 Section Customized 4,020.85Above RateKing Dual Plus Consoles include channel 1 & channel 2 harnessesB - SPEED SENSORSD - FLOW CONTROLPART NO.19093190941909619097DESCRIPTION1” Servo Valve, 150 PSI, 20161” High Pressure Servo Valve, 300 PSI, 2016Flanged Servo Valve (1” Butterfly),150 PSI, 2016200 Series Flange and 1.5” FPTFlanged Servo Valve (1.5” Butterfly),150 PSI, 2016200 Series Flange and 1.5” FPTELECTRIC MOTOR DRIVER KITSPART NO.0175801757DESCRIPTION40-Amp PWM Electric Motor Driver Kit40-Amp Standard Electric Motor Driver KitREPLACEMENT PARTSDESCRIPTIONRateKing Plus Console - 3 SectionRateKing Plus Console - 5 SectionRateKing Plus Console - 7 SectionRateKing Dual Plus Console - 3 SectionRateKing Dual Plus Console - 5 Section01531 310.07RateKing Dual Plus Console - 7 Section01533 168.23Console Mount Kit3 Section Branch HarnessC - FLOWMETER KITS5 Section Branch HarnessPART NO. DESCRIPTIONLIST PRICE7 Section Branch HarnessFM500 Flowmeter Kit (.5-5 GPM)(500 PSI)01500 563.18Flow Control Harness - Channel 101501 563.18FM750 GFN Flowmeter Kit (2-40 GPM)(150 PSI)Flow Control Harness - Channel 201504 1,016.29FM750 SS Flowmeter Kit (2-40 GPM)(500 PSI)Power Cable01650FM750 LF GFN Flowmeter Kit (.5-12 GPM)(150 PSI) 696.1110-Pin, 5’ M/P Extension Cable01505 1,102.05FM1000 SS Flowmeter Kit (3.5-70 GPM)(500 PSI)10-Pin, 10’ M/P Extension Cable01515 926.24FM270 Flowmeter Kit (3.5-70 GPM)(175 PSI)10-Pin, 15’ M/P Extension Cable01898 993.42FM270 LF Flowmeter Kit (.5-15 GPM)(175 PSI)10-Pin, 20’ M/P Extension Cable01514 959.12FM10/100 Flowmeter Kit (10-100 GPM)(175 PSI)Plus Series Single Pressure Sensor Cable01506 1,450.82FM1500 SS Flowmeter Kit (10-130 GPM)(500 PSI)Plus System Pressure Sensor, 150 PSI01519FM1500 SS LF Flowmeter Kit (3.5-70 GPM)(500 PSI) 1,512.29Plus System Pressure Sensor, 300 PSI01511 1,672.38FM2000 P Flowmeter Kit (19-198 GPM)(285 PSI)Plus System Single Pressure Harness Kit01513 2,189.81FM3000 P Flowmeter Kit (40-396 GPM)(855 PSI)Plus System Dual Pressure Harness KitGrimes, IA 800-351-1587 Gardner, KS 877-829-8502 Brimfield, IL 855-778-8500PART NO.014100142501526DESCRIPTIONAstro II GPS with 3-pin MPAstro 5 GPS with 3-pin MPVansco Radar Speed Sensor with Gen. II AdapterCableHall-effect Magnetic Wheel Speed Sensor Kit (with15’ Extension Cable)Hall-effect Magnetic Drive Shaft Speed Sensor Kit(without extension cable)LIST PRICE 558.89 751.86 1,372.21PART 7581876418765LIST PRICE 464.55 540.31 650.37 650.37LIST PRICE 873.35 873.35LIST PRICE 2,888.28 2,944.02 2,989.10 3,079.78 3,186.66 3,312.21 126.81 271.18 358.41 410.33 473.58 350.38 433.16 178.99 213.75 244.42 292.77 125.59 303.16 303.16 187.52147 349.80
MONITORS AND CONTROLSMONITORS AND CONTROLS148SPRAYMATE PLUSCompact in size, yet packed with all the powerful rate control and calculating features you’vecome to expect from Micro-Trak. Built to fit your changing needs with flexible system options likePWM control and three-way section valves. We’ve also added special features to ensure quickvalve response to changes in vehicle motion; helps minimize disappointing under-applications.Rest assured that valuable console information is secure by using the “Supervisor Lock-Out”feature to prevent deletion of critical calibration figures and data.SPRAYMATE PLUS CONTROLLER KITSPART NO. DESCRIPTION01866Spraymate Plus 3 Section with FM750 GFN Flow Meter & 1” Servo (LESS Speed Sensor)01352Spraymate Plus 3 Section with FM750 GFN Flow Meter & 1” Servo, Magnetic Wheel Sensor01975Spraymate Plus 3 Section with FM750 GFN Flow Meter & 1” Servo, Astro II GPS Speed SensorLIST PRICE 2,732.98 2,993.13 3,293.30The SprayMate Plus Retrofit kit is for those who have a Raven SCS440 that can no longer be repaired. This is a standardSprayMate Plus kit with the Micro-Trak branch harness removed. The 10’ Micro-Trak extension cable has been replace witha 10’ adapter cable. The adapter cable will have Raven connector on the implement end that can connect directly to theexisting Raven harness. The Raven flowmeter MUST be the 12 volt style.DESCRIPTIONSpraymate Plus 3 Section CustomizedLISTLIST PRICE 1,710.97B - SPEED SENSORSPART NO.0141001425015260153101533DESCRIPTIONAstro II GPS with 3-pin MPAstro 5 GPS with 3-pin MPVansco Radar Speed Sensor with Gen. II AdapterCableHall-effect Magnetic Wheel Speed Sensor Kit (with15’ Extension Cable)Hall-effect Magnetic Drive Shaft Speed Sensor Kit(without extension cable)C - FLOWMETER KITSPART TIONFM500 Flowmeter Kit (.5-5 GPM)(500 PSI)FM750 GFN Flowmeter Kit (2-40 GPM)(150 PSI)FM750 SS Flowmeter Kit (2-40 GPM)(500 PSI)FM750 LF GFN Flowmeter Kit (.5-12 GPM)(150 PSI)FM1000 SS Flowmeter Kit (3.5-70 GPM)(500 PSI)FM270 Flowmeter Kit (3.5-70 GPM)(175 PSI)FM270 LF Flowmeter Kit (.5-15 GPM)(175 PSI)FM10/100 Flowmeter Kit (10-100 GPM)(175 PSI)LIST PRICE 558.89 751.86 1,372.21 310.07LIST PRICE 563.18 563.18 1,016.29 696.11 1,102.05 926.24 993.42 959.1221779SPEEDWIRELESSINPUTD - FLOW CONTROLPART NO.19093190941909619097DESCRIPTION1” Servo Valve, 150 PSI, 20161” High Pressure Servo Valve, 300 PSI, 2016Flanged Servo Valve (1” Butterfly),150 PSI, 2016200 Series Flange and 1.5” FPTFlanged Servo Valve (1.5” Butterfly),150 PSI, 2016200 Series Flange and 1.5” FPTELECTRIC MOTOR DRIVER KITSPART NO.0175801757 168.23SPRAYMATE PLUSSWITCHPOWERSWITCHSEAPART NO.01349PLESelect from A, B, C and D to build custom systems.A - CONSOLES WITH MAIN HARNESSDESCRIPTION40-Amp PWM Electric Motor Driver Kit40-Amp Standard Electric Motor Driver KitREPLACEMENT PARTSPART 75718758187642177921778DESCRIPTIONSpraymate Plus Console - 3 SectionConsole Mount Kit3 Section Branch HarnessPower Cable10-Pin, 5’ M/P (5/5)Extension Cable10-Pin, 10’ M/P (5/5) Extension Cable10-Pin, 15’ M/P (5/5) Extension Cable10-Pin, 20’ M/P (5/5) Extension CablePlus Series Single Pressure Sensor CablePlus System Pressure Sensor, 150 PSIPlus System Pressure Sensor, 300 PSIPlus System Single Pressure Harness KitPower Switch KitRun/Hold Switch KitSPRAYERSPECIALTIESLOGSPRAYMATE PLUS CUSTOMIZEDECPRIC ATANTLIST PRICE 1,578.04OUPART NO. DESCRIPTION02026Spraymate Plus Raven Retrofit Kit (LESS Speed Sensor)A P P LY D I S CLIST PRICE 464.55 540.31 650.37 650.37LIST PRICE 873.35 873.35LIST PRICE 1,778.05 58.56 352.68 183.61 189.43 280.87 337.66 414.80 125.59 303.16 303.16 187.52 126.57 126.5914315RUN/HOLDSWITCH217781431614313System DiagramSprayMate Plus148Grimes, IA800-351-1587SECTION 1SECTION 2SECTION 3CONTROLFLOWREMOTERUN/HOLDMULTIFUNCTION Gardner, KS877-829-8502 1909319096NEW STYLE MICRO-TRACKSERVO VALVESBrimfield, IL 855-778-8500
MONITORS AND CONTROLSSimple Precision.SprayMate II is a 3-section automatic rate controller for liquid and anhydrous withbuilt-in boom switches on the console. Its all-in-one design makes it a convenient, simple user friendlypackage at a very economical price. On-the-go rate adjustment in Auto control mode Minimum flow feature to ensure properapplication pattern as ground speed slows toextremes Solenoid and ball valve compatible (2 or 3 wirevalves) Flow-based control Push-button auto/manual feature for spottreatments Precise rate control regardless of fieldconditions Controls electric and hydraulic valves/motors Three Boom Switches located on top of unit NH3 compatibleSPEED SENSORSSPRAYMATE II CONTROLLER KITSPART NO.01171DESCRIPTIONSprayMate II Controller Kit with FM750 GFNFlowmeter, 1” Servo, (LESS Speed Sensor)COMPONENTSPART SCRIPTIONSprayMate II ConsoleConsole Mount KitOwner’s ManualFM750 GFN Flowmeter Kit1” Electric Servo Valve - 2016Boom/Servo/Flow HarnessPower Cable72” Ignition Cable120” 10-Pin Extension CableLIST PRICE 2,185.53LIST PRICE 1,569.38 58.56 51.00 563.18 464.55 387.95 183.61 53.96 280.87PART NO.014100152601531DESCRIPTIONAstro II GPS with 3-pin MPVansco Radar Speed Sensor with Gen. II AdapterCableHall-effect Magnetic Wheel Speed Sensor Kit (with15’ Extension Cable)RADAR ADAPTER CABLESPART 926DESCRIPTIONIn-Cab John Deere Metri-Pack 8000/9000 SeriesIn-Cab John Deere “Y” ConnectorDickey-John Radar Amp ConnectorDickey-John Radar Cannon ConnectorDickey-John Radar Deutsch ConnectorDickey-John Radar Packard ConnectorDickey-John Radar Ford ConnectorRaven Radar Conxall ConnectorMagnavox & Phillips Radar Packard ConnectorVansco Radar Amp ConnectorMONITORS AND CONTROLS149SPRAYMATE IILIST PRICE 558.89 1,372.21 310.07LIST PRICE 87.41 102.26 188.02 188.02 188.02 188.02 188.02 188.02 188.02 102.26ROADMASTER ADESCRIPTIONRoadMaster Customized (standard control)LIST PRICE 2,242.70PART NO.01757PART NO.014100142501526DESCRIPTIONAstro II GPS with 3-pin MPAstro 5 GPS with 3-pin MPVansco Radar Speed Sensor with Gen. II AdapterCableHall-effect Magnetic Wheel Speed Sensor Kit (with15’ Extension Cable)Hall-effect Magnetic Drive Shaft Speed Sensor Kit(without extension cable)LIST PRICE 558.89 751.86 1,372.21RADAR ADAPTER CABLESB - SPEED SENSORS0153101533SERVO VALVE (BUTTERFLY) KITSPART NO.190931909619097 310.07 168.23PART 0-Amp Standard Electric Motor Driver KitDESCRIPTIONFM500 Flowmeter - .5-5 GPMFM750P Flowmeter Kit - 2-40 GPMFM750SS Flowmeter Kit - 2-40 GPMFM1000SS Flowmeter Kit - 3.5-70 GPMFM270 Flowmeter Kit - 3.5-70 GPMFM10/100 Flowmeter Kit - 10-100 GPMFM3000P Flowmeter Kit - 40-396 GPMDESCRIPTIONLIST PRICE ROADMASTER OPTIONSPART NO. DESCRIPTION1” Servo Valve - 2016 464.5501189Wireless Remote KitFlanged Servo Valve(1” butterfly, 1.5” threads) 650.3701744Blast/Run/Hold Remote Switch BoxFlanged Servo Valve(1.5” butterfly,1.5” threads) 650.37Grimes, IA 800-351-1587 Gardner, KS 877-829-8502 Brimfield, IL 855-778-8500NTSPECIALTIESOUPLEPART NO.01590LOGLISTThe RoadMaster is a multi-purpose electronic control system with a wide range of applications.Highway maintenance uses include regulating the flow of: liquid de-icer and anti-icers, roadside sprayproducts, and dust-control agents. Also ideal for turf maintenance applications of herbicides, fungicides,insecticides, and fertilizers. Raise your profitability by maintaining exact application rates of thesevaluable products. Four Operating Modes Keylock SwitchECPRIC ATA Selectable Servo Drive Options Built-in Alarm MessagesSPRAYER Built-in VRA/AVL Communications Built-in Audible Alarm Extensive Downloadable Data List Emergency StopSEA P P LY D I S C Blast SwitchELECTRIC MOTOR DRIVER KITA - CONSOLES WITH MAIN HARNESSLIST PRICE 873.35LIST PRICE 563.18 563.18 1,016.29 1,102.05 926.24 959.12 2,189.81LIST PRICE 821.35 265.87149
MONITORS AND CONTROLSMONITORS AND CONTROLS150Calc-An-Acre II comes with branch harness consisting of 10’ speed and power cables and 9”pigtails for RPM and RUN/HOLDIn addition to providing accurate speed,area and distance measurement; theCalc-An-Acre II will now independentlymonitor the RPM of a shaft. It includes3 independent area counters, twoindependent hour counters, an areaper hour function and width reductionfeature to measure the effectivecoverage area in spraying applications.FLOWMATEPART 0901318401539DESCRIPTIONCALC-AN-ACRE IISensor BracketMagnet ClipSpeed SensorRun/Hold Sensor CableSpeed Sensor KitMagnets - 6 PackRun/Hold KitRelay KitSpeed, Run/Hold, Power HarnessOwners ManualShaft RPM Module KitLIST PRICE 768.57 28.41 18.74 166.98 120.26 336.45 30.69 265.28 157.93 233.16 51.00 178.25FlowMate comes standard with one 15’ and one 25’ 3-pin extension and one 10’ power cable.FLOWMATE PART NO.01741Ensures accurate flow for liquid fertilizer and otherliquid applications. Utilizes flowmeter to determine 01739Gal/Min and Total Gallons Applied. Verifies grounddrive pump settins and detects faulty pump, broken 18154chains and empty tank. Easy to install, setup and 18155calibate. Low cost, economical solution!1815750346DESCRIPTIONFlowMate Monitor with FM750 GFNFlowMate Monitor - Customized(Select Flow Meter)FlowMate ConsoleFlowMate 10’ Power CableFlowMate Fuse/Terminal KitInstruction Sheet, FlowMate LIST PRICE 1,306.24 656.42 780.44 58.96 20.20 28.50Flow-Trak II comes with branch harness consisting of 10’ speed, flow and power cables and 12”pigtails for optional relay control and run/holdFLOW TRAK IIFeatures Include:SPRAYERNTSPECIALTIESOUASEECPRIC ATALOGPLE Rate Flow Rate Volume Area & Area Per HourLIST Ground Speed Linear Distance TraveledA P P LY D I S CSHAFT-TRAKShaft & Bin Level MonitorMonitors up to 6 independent shafts ormonitor up to 3 shafts and 3 bin levels.Sends information to allow operator toknow if shaft or shafts are turning under45 RPM or when level of bin is belowsensor. No programming, plug & go!Audible alarm. Avoid skipped seedingareas.Flo-Pro Grimes, IA800-351-1587 Gardner, KS17193DESCRIPTIONFlowTrak II Monitor with FM750 GFNFlowTrak II Monitor - Customized(Select Flow Meter and Speed Sensor)Installation/Operator’s ManualLIST PRICE 1,804.32 1,149.55 51.00Shaft Trak comes with two 15’ 10-pin extensions and a 12” sensor branch. Sensors come with5’ cables.SHAFT-TRAK PART haftTrak kit w/ 1 sensorShaftTrak kit w/ 2 sensorShaftTrak kit w/ 3 sensorShaftTrak kit w/ 4 sensorShaftTrak kit w/ 5 sensorShaftTrak kit w/ 6 sensorInstruction SheetLIST PRICE 981.33 1,124.81 1,185.84 1,281.50 1,385.40 1,482.71 28.50Flo-Pro comes with the Console, 10’ Branch Harness, Power Cable w/ 10A fuse, ConsoleMount Kit, 10-Pack of 14” Cable Ties & System ManualThe Flo-Pro is a two channel controllerdesigned to accurately meter anddispense liquids. It is intended to be partof a complete batching system consistingof the Flo-Pro Console, two flowmeters,two control valves, and a connection foran optional remote run/hold switch.150PART NO.0117001021FLO-PRO PART NO.02016DESCRIPTIONFlo-Pro Kit; LESS FlowmeterLIST PRICE 1,347.91198361983419835131811291019830Flo-Pro ConsoleFlo-Pro 10’ Branch HarnessFlo-Pro 10’ Power Cable w/ 10A fuseConsole Mount Kit10-pack 14” Cable TiesFlo-Pro System Manual 1,754.17 362.26 86.67 58.56 13.91 51.00877-829-8502 Brimfield, IL 855-778-8500
MONITORS AND CONTROLSFM750LF 01650LOW FLOWFM750 01501FM750SS 01504SPRAYMATE PLUS CONTROLLER KITSPART NO.01500016500150101504015050151501514MODEL NO.FM500FM750LF (Low Flow)FM750PFM750SSFM1000SSFM270FM10-100FM750PPARTS DRAWINGINLET/OUTLET CONNECTIONS1/2” Female NPT3/4” Female NPT3/4” Female NPT3/4” Female NPT1” Female NPT2” Standard Port Flange (200)2” Standard Port Flange (200)GPM.50 to 5 GPM.50 to 12 GPM2 to 40 GPM2 to 40 GPM3.5 to 70 GPM3.5 to 70 GPM10 to 100 GPMMAKEPolyPolyPolyStainless SteelStainless SteelPolyPolyFM10-100 01514K-FACTOR1550.0480.0150.0155.0LIST PRICE 563.18 696.11 563.18 1,016.29 1,102.05 926.24 959.12145.0100.0FLOW METER REPLACEMENT PARTSQuad-RingP/N- 13783Quad-ringSensor Nut P/N 13783P/N - 10060FLOW METER REPLACEMENT PARTSHousing FM750 GFNHousing FM750 GFNP/N - 21016HousingFM750Housing FM750GFNGFN(Non Sensor)P/N- 21016ASPECIALTIES21016DESCRIPTIONFM500 O-ringFM750 SS & N and FM1000 SS Gasket (Teflon)FM750 GFN Quad O-ringTurbine for: FM750 GFN, SS & N, FM1000 SS, FM270,FM10/100 and FM1500SSFM750 GFN & LF Housing with Bearing (1/2 of flowmeter)LIST PRICE 9.70 14.27 46.85 195.71 317.65NTSPRAYERPART NO.10605101371378314836OUPLESEECPRIC ATALOGLISTTurbineTurbineP/N 14836P/N - 14836FM1000SS 01505MONITORS AND CONTROLSFM500 01500151FLOW METERSEMD - ELECTRIC MOTOR DRIVERA P P LY D I S CThe Electric Motor Driver (EMD) enables all of our rate controllers, SprayMate II, MT-2405F II, SprayMate Plus, RateKing Plus, RateKing Dual Plus and RoadMaster, to control the rate of flow by regulating thespeed of a 12 volt pump. It can also be integrated into most major-brand control systems.The EMD replaces the electric servo valve and will control most 12v pumps with up to a max of 40 amps.PART NO.DESCRIPTIONLIST PRICEPART TION40 Amp EMD - 4’ Power Cable40 Amp Standard EMD Module40 Amp PWM ModuleCable, 2-pin M/P 480 PowerCable, 2-pin M/P 480 MotorMotor Y-Cable, 2-pin M/P 480 x M/P 480Multi-Section EMD Adapter Cable (SprayMate II)Master Control Kit EMD Multi-Section (MT-3405F II)LIST PRICE 86.93 955.78 955.78 307.61 90.65 166.16 144.23 611.780175740 Amp Standard Electric Motor Driver Kit0175840-Amp PWM Electric Motor Driver KitCOMPONENTS 873.35 873.35VANSCO RADAR SPEED SENSOR Mount Height: 12” to 48” Speed Range: 2 to 44 mph Power Source: 12 Volt Dimensions: 3.7” x 4” x 9.3”PART NO.DESCRIPTIONLIST PRICEPART NO.1401914024140251403014031DESCRIPTIONLIST PRICE4-pin DJ to 3-pin M/P with Radar Interface (Vansco Interface) 163.28Radar Interface Cable, 4-pin DJ to 2-pin Rolco - 1’ 158.334-pin DJ to 3-pin W/P with Radar Interface (Vansco Interface) 158.334-pin DJ Amp to Raven CONXALL Connector - 1’ 212.764-pin DJ Amp to Spraying Systems DEUTSCH Connector - 1’ 212.76Gardner, KS 877-829-8502 Brimfield, IL 855-778-850001526Vansco Radar Speed Sensor (Includes Adapter Cable for New Micro-Trak Products) 1,372.21ADAPTER CABLESGrimes, IA800-351-1587 151
MONITORS AND CONTROLSMONITORS AND CONTROLS152PART NO.1308313762137631377313774DESCRIPTIONFlow, Run/Hold Servo Boom 1 (Harness)Booms 2 & 3 Relief (Harness)Booms 4 & 5 (Harness)Owners ManualMT3405-F-II Console Mounting KitLIST PRICE 302.02 186.90 211.27 51.00 126.81015000150101504015050151501514FM500 (1/2”) .5-5 GPMFM750P (3/4”) 2-40 GPM - PolyFM750SS (3/4”) 2-40 GPM - StainlessFM1000SS (1”) 3.5-70 GPM - StainlessFM270 (2” Flange) 3.5-70 GPMFM10-100 (2” Flange) 10-100 GPM 563.18 563.18 1,016.29 1,102.05 926.24 959.1213205132061320713208132095’ M/P 3 Pin Extension Cable10’ M/P 3 Pin Extension Cable15’ M/P 3 Pin Extension Cable20’ M/P 3 Pin Extension Cable25’
Delphi connector Weather Pack Shroud-pin. 01414 01429 eeet. Sprayer Control Deutsch DT 3-Pin. 01417 01432 eeet. 55 Sprayer Control Deutsch CMP 3-Pin. 01419 01433 inier. Computer acts, Acre Commander, Spray Commander ITT-Cannon Sure-Seal 3-Pin. 01420 01435 ardi. Sprayers (sprayer input connection) AMP Superseal 3-Pin. 01847 01848 .
