Transcription
Safety Data SheetRevision Number: 005.0Issue date: 10/06/20171. PRODUCT AND COMPANY IDENTIFICATIONProduct name:LOCTITE 565 PST PIPE SEALANT IDH number:88551THREAD SEALANTProduct type:Item number:Anaerobic Sealant56531Restriction of Use:Region:None identifiedUnited StatesCompany address:Contact information:Henkel CorporationTelephone: (860) 571-5100One Henkel WayMEDICAL EMERGENCY Phone: Poison Control CenterRocky Hill, Connecticut 060671-877-671-4608 (toll free) or 1-303-592-1711TRANSPORT EMERGENCY Phone: CHEMTREC1-800-424-9300 (toll free) or 1-703-527-3887Internet: www.henkelna.com2. HAZARDS IDENTIFICATIONEMERGENCY OVERVIEWWARNING:CAUSES SKIN IRRITATION.CAUSES SERIOUS EYE IRRITATION.MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED ORREPEATED EXPOSURE.HAZARD CLASSSKIN IRRITATIONEYE IRRITATIONSPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSUREHAZARD CATEGORY22A2PICTOGRAM(S)Precautionary StatementsPrevention:Response:Storage:Disposal:Do not breathe vapors, mist, or spray. Wash affected area thoroughly after handling. Wearprotective gloves, eye protection, and face protection.IF ON SKIN: Wash with plenty of water. IF IN EYES: Rinse cautiously with water for severalminutes. Remove contact lenses, if present and easy to do. Continue rinsing. Get medicalattention if you feel unwell. If skin irritation occurs: Get medical attention. If eye irritationpersists: Get medical attention. Take off contaminated clothing.Not prescribedDispose of contents and/or container according to Federal, State/Provincial and localgovernmental regulations.Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of theUnited Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).See Section 11 for additional toxicological information.3. COMPOSITION / INFORMATION ON INGREDIENTSIDH number: 88551Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 1 of 6
Hazardous Component(s)CAS NumberPercentage*Ethene, tetrafluoro-, homopolymerTitanium dioxideTreated fumed silicaSaccharinCumene hydroperoxideEthylene -15-9107-21-198-82-81-51-51-51-51-50.1 - 10.1 - 1* Exact percentages may vary or are trade secret. Concentration range is provided to assist users in providing appropriate protections.4. FIRST AID MEASURESInhalation:Move to fresh air. If breathing is difficult, give oxygen. If not breathing, giveartificial respiration. Get medical attention.Skin contact:Remove contaminated clothing and footwear. Wash clothing before reuse.Immediately flush skin with plenty of water (using soap, if available). Getmedical attention.Eye contact:Get medical attention. Rinse immediately with plenty of water, also under theeyelids, for at least 15 minutes.Ingestion:Never give anything by mouth to an unconscious person. Do not inducevomiting. Get medical attention.Symptoms:See Section 11.5. FIRE FIGHTING MEASURESExtinguishing media:Water spray (fog), foam, dry chemical or carbon dioxide.Special firefighting procedures:Wear self-contained breathing apparatus and full protective clothing, such asturn-out gear. In case of fire, keep containers cool with water spray.Unusual fire or explosion hazards:Uncontrolled polymerization may occur at high temperatures resulting inexplosions or rupture of storage containers.Hazardous combustion products:Oxides of carbon. Oxides of sulfur. Oxides of nitrogen. Toxic fluorinecompounds. Irritating organic vapours.6. ACCIDENTAL RELEASE MEASURESUse personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotectedpersonnel.Environmental precautions:Do not allow product to enter sewer or waterways.Clean-up methods:Remove all sources of ignition. Evacuate and ventilate spill area; dike spill toprevent entry into water system; wear full protective equipment during cleanup. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder,universal binder, sawdust). Scrape up as much material as possible. Store in apartly filled, closed container until disposal. Refer to Section 8 "ExposureControls / Personal Protection" prior to clean up.IDH number: 88551Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 2 of 6
7. HANDLING AND STORAGEHandling:Keep container closed. Use only with adequate ventilation. Prevent contactwith eyes, skin and clothing. Do not breathe vapor and mist. Washthoroughly after handling. Refer to Section 8.Storage:For safe storage, store at or below 38 C (100.4 F)Keep in a cool, well ventilated area away from heat, sparks and open flame.Keep container tightly closed until ready for use.8. EXPOSURE CONTROLS / PERSONAL PROTECTIONEmployers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposurecontrols and protective equipment for each task performed.Hazardous Component(s)Ethene, tetrafluoro-, homopolymerTitanium dioxideTreated fumed silicaSaccharinCumene hydroperoxideEthylene glycolCumeneACGIH TLVOSHA PELAIHA WEELOTHERNoneNoneNone10 mg/m3 TWA Totaldust.5 mg/m3 TWARespirable fraction.NoneNoneNoneNoneNone1 ppm (6 mg/m3)TWA(SKIN)None10 mg/m3 TWAInhalable dust.3 mg/m3 TWARespirable fraction.None15 mg/m3 PEL Totaldust.15 MPPCF TWARespirable fraction.15 mg/m3 TWA Totaldust.50 MPPCF TWATotal dust.5 mg/m3 TWARespirable fraction.15 mg/m3 TWA Totaldust.5 mg/m3 TWARespirable fraction.NoneNoneNone25 ppm TWA Vaporfraction50 ppm STEL Vaporfraction10 mg/m3 STELAerosol, inhalable.NoneNoneNone50 ppm TWA50 ppm (245 mg/m3)PEL(SKIN)NoneNone10 mg/m3 TWANoneEngineering controls:Provide adequate local exhaust ventilation to maintain worker exposure belowexposure limits.Respiratory protection:Use NIOSH approved respirator if there is potential to exceed exposurelimit(s).Eye/face protection:Safety goggles or safety glasses with side shields. Full face protection shouldbe used if the potential for splashing or spraying of product exists. Safetyshowers and eye wash stations should be available.Skin protection:Use chemical resistant, impermeable clothing including gloves and either anapron or body suit to prevent skin contact. Neoprene, Butyl-rubber, or nitrilerubber gloves.IDH number: 88551Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 3 of 6
9. PHYSICAL AND CHEMICAL PROPERTIESPhysical state:Color:Odor:Odor threshold:pH:pH:Vapor pressure:Boiling point/range:Melting point/ range:Specific gravity:Vapor density:Flash point:Flammable/Explosive limits - lower:Flammable/Explosive limits - upper:Autoignition temperature:Flammability:Evaporation rate:Solubility in water:Partition coefficient (n-octanol/water):VOC content:Viscosity:Decomposition temperature:Liquid, PasteWhiteMildNot available.Not applicableNot applicable 5 mm hg (27 C (80.6 F)) 149 C ( 300.2 F)Not available.1.1Not available. 93 C ( 199.4 F)Not available.Not available.Not available.Not applicableNot available.SlightNot available.0.11 %; 1.06 g/l Method 40 CFR Part 63 Appendix A to Subpart PPPPNot available.Not available.10. STABILITY AND REACTIVITYStability:Stable under normal conditions of storage and use.Hazardous reactions:None under normal processing. Polymerization may occur at elevated temperature or in thepresence of incompatible materials.Hazardous decompositionproducts:Oxides of carbon. Toxic fluorine compounds. Oxides of nitrogen. Oxides of sulfur. Irritatingorganic vapours.Incompatible materials:Strong oxidizing agents.Reactivity:Not available.Conditions to avoid:Elevated temperatures. Heat, flames, sparks and other sources of ignition. Store away fromincompatible materials.11. TOXICOLOGICAL INFORMATIONRelevant routes of exposure:IDH number: 88551Skin, Inhalation, Eyes, IngestionProduct name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 4 of 6
Potential Health Effects/SymptomsInhalation:Skin contact:Eye contact:Ingestion:Inhalation of vapors or mists of the product may be irritating to the respiratory system.Causes skin irritation.Causes serious eye irritation.May cause gastrointestinal tract irritation if swallowed.Hazardous Component(s)LD50s and LC50sImmediate and Delayed Health EffectsEthene, tetrafluoro-, homopolymerNoneTitanium dioxideNoneNo Target OrgansIrritant, Respiratory, Some evidence ofcarcinogenicityIrritantNo Target OrgansAllergen, Central nervous system, Corrosive,Irritant, MutagenBlood, Bone Marrow, Central nervoussystem, Developmental, Eyes, Irritant,Kidney, Liver, MetabolicTreated fumed silicaSaccharinNoneOral LD50 (Mouse) 17 g/kgCumene hydroperoxideInhalation LC50 (Mouse, 4 h) 200 mg/lEthylene glycolCumeneOral LD50 (Rat) 5.89 g/kgOral LD50 (Mouse) 14.6 g/kgDermal LD50 (Rabbit) 9,530 mg/kgOral LD50 (Rat) 2.91 g/kgOral LD50 (Rat) 1,400 mg/kgInhalation LC50 (Rat, 4 h) 8000 ppmHazardous Component(s)Ethene, tetrafluoro-, homopolymerTitanium dioxideTreated fumed silicaSaccharinCumene hydroperoxideEthylene glycolCumeneCentral nervous system, Irritant, LungOSHA CarcinogenNTP CarcinogenIARC CarcinogenNoNoNoNoNoNoReasonably Anticipated to bea Human Carcinogen.NoGroup 2BNoNoNoNoNoNoNoNoNoNoGroup 2BNo(Specifically Regulated)12. ECOLOGICAL INFORMATIONEcological information:Not available.13. DISPOSAL CONSIDERATIONSInformation provided is for unused product only.Recommended method of disposal:Follow all local, state, federal and provincial regulations for disposal.Hazardous waste number:Not a RCRA hazardous waste.14. TRANSPORT INFORMATIONThe transport information provided in this section only applies to the material/formulation itself, and is not specific to anypackage/configuration.U.S. Department of Transportation Ground (49 CFR)Proper shipping name:RQ, Environmentally hazardous substance, liquid, n.o.s.Hazard class or division:9Identification number:UN 3082Packing group:IIIDOT Hazardous deIDH number: 88551Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 5 of 6
International Air Transportation (ICAO/IATA)Proper shipping name:Hazard class or division:Identification number:Packing group:RQ, Environmentally hazardous substance, liquid, n.o.s.9UN 3082IIIWater Transportation (IMO/IMDG)Proper shipping name:Hazard class or division:Identification number:Packing group:RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.9UN 3082III15. REGULATORY INFORMATIONUnited States Regulatory InformationTSCA 8 (b) Inventory Status:TSCA 12 (b) Export Notification:CERCLA/SARA Section 302 EHS:CERCLA/SARA Section 311/312:CERCLA/SARA Section 313:CERCLA Reportable quantity:California Proposition 65:All components are listed or are exempt from listing on the Toxic Substances Control ActInventory.Ethene, tetrafluoro-, homopolymer (CAS# 9002-84-0).None above reporting de minimis.Immediate Health, Delayed HealthThis product contains the following toxic chemicals subject to the reporting requirements ofsection 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40CFR 372). Saccharin (CAS# 81-07-2). Cumene hydroperoxide (CAS# 80-15-9).Cumene hydroperoxide (CAS# 80-15-9) 10 lbs. (4.54 kg)This product contains a chemical known in the State of California to cause cancer. Thisproduct contains a chemical known to the State of California to cause birth defects or otherreproductive harm.Canada Regulatory InformationCEPA DSL/NDSL Status:Contains one or more components listed on the Non-Domestic Substances List. All othercomponents are listed on or are exempt from listing on the Domestic Substances List.Components listed on the NDSL must be tracked by all Canadian Importers of Record asrequired by Environment Canada. They may be imported into Canada in limited quantities.Please contact Regulatory Affairs for additional details.16. OTHER INFORMATIONThis safety data sheet contains changes from the previous version in sections: 2Prepared by:Product Safety and Regulatory AffairsIssue date:10/06/2017DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, HenkelCorporation and its affiliates (“Henkel”) does not assume responsibility for any results obtained by persons over whose methodsHenkel has no control. It is the user’s responsibility to determine the suitability of Henkel’s products or any production methodsmentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property andpersons against any hazards that may be involved in the handling and use of any Henkel’s products. In light of the foregoing,Henkel specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particularpurpose, arising from sale or use of Henkel’s products. Henkel further disclaims any liability for consequential or incidental damagesof any kind, including lost profits.IDH number: 88551Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANTPage 6 of 6
Product name: LOCTITE 565 PST PIPE SEALANT THREAD SEALANT Page 3 of 6 7. HANDLING AND STORAGE Handling: Keep container closed. Use only with adequate ventilation. Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist. Wash thoroughly after handling. Refer to Section 8. Storage: For safe storage, store at or below 38 C (100.4 F) Keep in a cool, well ventilated .
