WIXLIB

http://www.techni-tool.comSafety Data SheetRevision Number: 008.0Issue date: 08/21/20141. PRODUCT AND COMPANY IDENTIFICATIONProduct name:Loctite(R) 242(R) ThreadlockerMedium StrengthAnaerobic SealantNone identifiedProduct type:Restriction of Use:Company address:Henkel CorporationOne Henkel WayRocky Hill, Connecticut 06067IDH number:230718Item number:24205Region:United StatesContact information:Telephone: (860) 571-5100MEDICAL EMERGENCY Phone: Poison Control Center1-877-671-4608 (toll free) or 1-303-592-1711TRANSPORT EMERGENCY Phone: CHEMTREC1-800-424-9300 (toll free) or 1-703-527-3887Internet: www.henkelna.com2. HAZARDS IDENTIFICATIONEMERGENCY OVERVIEWWARNING:CAUSES SKIN AND EYE IRRITATION.MAY CAUSE AN ALLERGIC SKIN REACTION.HAZARD CLASSHAZARD CATEGORY22B1SKIN IRRITATIONEYE IRRITATIONSKIN SENSITIZATIONPICTOGRAM(S)Precautionary id breathing vapors, mist, or spray. Wash thoroughly after handling. Contaminated workclothing should not be allowed out of the workplace. Wear protective gloves.IF ON SKIN: Wash with plenty of soap and water. IF IN EYES: Rinse cautiously with water forseveral minutes. Remove contact lenses, if present and easy to remove. Continue rinsing. Ifskin irritation or rash occurs: Get medical attention. If eye irritation persists: Get medicalattention. Take off contaminated clothing.Not prescribedDispose of contents and/or container according to Federal, State/Provincial and localgovernmental regulations.Classification complies with OSHA Hazard Communication Standard (29 CFR 1910.1200) and is consistent with the provisions of theUnited Nations Globally Harmonized System of Classification and Labeling of Chemicals (GHS).See Section 11 for additional toxicological information.3. COMPOSITION / INFORMATION ON INGREDIENTSHazardous Component(s)CAS NumberPercentage*Polyglycol dimethacrylateProprietary60 - 100IDH number: 230718Product name: Loctite(R) 242(R) Threadlocker Medium StrengthPage 1 of 6http://www.techni-tool.com

http://www.techni-tool.comPolyglycol oleateSaccharinSilica, amorphous, fumed, crystal-freeCumene 7-2112945-52-580-15-957-55-698-82-810 - 301-51-51-51-50.1 - 1* Exact percentage is a trade secret. Concentration range is provided to assist users in providing appropriate protections.4. FIRST AID MEASURESInhalation:Move to fresh air. If breathing is difficult, give oxygen. If not breathing, giveartificial respiration. Get medical attention.Skin contact:Immediately flush skin with plenty of water (using soap, if available). Removecontaminated clothing and footwear. Wash clothing before reuse. Get medicalattention.Eye contact:Rinse immediately with plenty of water, also under the eyelids, for at least 15minutes. Get medical attention.Ingestion:DO NOT induce vomiting unless directed to do so by medical personnel.Never give anything by mouth to an unconscious person. Get medicalattention.Symptoms:See Section 11.5. FIRE FIGHTING MEASURESExtinguishing media:Water spray (fog), foam, dry chemical or carbon dioxide.Special firefighting procedures:Wear self-contained breathing apparatus and full protective clothing, such asturn-out gear. In case of fire, keep containers cool with water spray.Unusual fire or explosion hazards:Uncontrolled polymerization may occur at high temperatures resulting inexplosions or rupture of storage containers.Hazardous combustion products:Oxides of carbon. Oxides of sulfur. Oxides of nitrogen. Irritating organicvapours.6. ACCIDENTAL RELEASE MEASURESUse personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotectedpersonnel.Environmental precautions:Do not allow product to enter sewer or waterways.Clean-up methods:Remove all sources of ignition. Evacuate and ventilate spill area; dike spill toprevent entry into water system; wear full protective equipment during cleanup. Soak up with inert absorbent material (e.g. sand, silica gel, acid binder,universal binder, sawdust). Scrape up as much material as possible. Store in apartly filled, closed container until disposal. Refer to Section 8 "ExposureControls / Personal Protection" prior to clean up.IDH number: 230718Product name: Loctite(R) 242(R) Threadlocker Medium StrengthPage 2 of 6http://www.techni-tool.com

http://www.techni-tool.com7. HANDLING AND STORAGEHandling:Use only with adequate ventilation. Prevent contact with eyes, skin andclothing. Do not breathe vapor and mist. Wash thoroughly after handling.Keep container closed. Refer to Section 8.Storage:For safe storage, store between 0 C (32 F) and 32 C (89.6 F)Keep in a cool, well ventilated area away from heat, sparks and open flame.Keep container tightly closed until ready for use.For information on product shelf life contact Henkel Customer Service at (800) 243-4874.8. EXPOSURE CONTROLS / PERSONAL PROTECTIONEmployers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposurecontrols and protective equipment for each task performed.Hazardous Component(s)Polyglycol dimethacrylatePolyglycol oleateSaccharinSilica, amorphous, fumed, crystal-freeACGIH TLVOSHA PELAIHA WEELOTHERNoneNoneNone10 mg/m3 TWAInhalable dust.3 mg/m3 TWARespirable fraction.NoneNoneNoneNoneNoneNoneNoneNoneNone20 MPPCF TWA0.8 mg/m3 TWANoneNoneCumene hydroperoxideNoneNonePropane-1,2-diolNoneNone50 ppm TWA50 ppm (245 mg/m3)PEL(SKIN)Cumene1 ppm (6 mg/m3)TWA(SKIN)10 mg/m3 TWAAerosol.NoneNoneNoneNoneEngineering controls:Provide adequate local exhaust ventilation to maintain worker exposure belowexposure limits.Respiratory protection:Use NIOSH approved respirator if there is potential to exceed exposurelimit(s).Eye/face protection:Safety goggles or safety glasses with side shields. Full face protection shouldbe used if the potential for splashing or spraying of product exists. Safetyshowers and eye wash stations should be available.Skin protection:Use chemical resistant, impermeable clothing including gloves and either anapron or body suit to prevent skin contact. Neoprene gloves. Butyl rubbergloves. Natural rubber gloves.9. PHYSICAL AND CHEMICAL PROPERTIESPhysical state:Color:Odor:Odor threshold:pH:Vapor pressure:Boiling point/range:Melting point/ range:Specific gravity:Vapor density:Flash point:Flame projection:Flammable/Explosive limits - lower:Flammable/Explosive limits - upper:IDH number: 230718LiquidBlueMildNot available.Not applicable 5 mm hg (27 C (80.6 F)) 149 C ( 300.2 F)Not available.1.1 at 23.9 C (75.02 F)Not available. 93.3 C ( 199.94 F) Tagliabue closed cupNot applicable2.6 % (propylene glycol)12.5 % (propylene glycol)Product name: Loctite(R) 242(R) Threadlocker Medium StrengthPage 3 of 6http://www.techni-tool.com

http://www.techni-tool.comAutoignition temperature:Evaporation rate:Solubility in water:Partition coefficient (n-octanol/water):VOC content:Viscosity:Decomposition temperature:Not determinedNot available.SlightNot available.0.56 %; 6.17 g/lNot available.Not available.10. STABILITY AND REACTIVITYStability:Stable under normal conditions of storage and use.Hazardous reactions:None under normal processing. Polymerization may occur at elevated temperature or in thepresence of incompatible materials.Hazardous decompositionproducts:Oxides of carbon. Oxides of sulfur. Oxides of nitrogen. Irritating organic vapours.Incompatible materials:Strong oxidizing agents. Free radical initiators. Strong reducing agents. Alkalis. Oxygenscavengers. Other polymerization initiators. Copper. Iron. Zinc. Aluminum. Rust.Reactivity:Not available.Conditions to avoid:Elevated temperatures. Heat, flames, sparks and other sources of ignition. Store away fromincompatible materials.11. TOXICOLOGICAL INFORMATIONRelevant routes of exposure:Skin, Inhalation, Eyes, IngestionPotential Health Effects/SymptomsInhalation:Skin contact:Eye contact:Ingestion:Hazardous Component(s)Inhalation of vapors or mists of the product may be irritating to the respiratory system.Causes skin irritation. May cause allergic skin reaction.Causes eye irritation.May cause gastrointestinal tract irritation if swallowed.LD50s and LC50sImmediate and Delayed Health EffectsNoneNoneNoneNoneAllergen, IrritantIrritantNo Target OrgansNuisance dustAllergen, Central nervous system, Corrosive,Irritant, MutagenPolyglycol dimethacrylatePolyglycol oleateSaccharinSilica, amorphous, fumed, crystal-freeCumene hydroperoxidePropane-1,2-diolCumeneHazardous Component(s)Polyglycol dimethacrylatePolyglycol oleateSaccharinSilica, amorphous, fumed, crystal-freeCumene hydroperoxidePropane-1,2-diolCumeneIDH number: 230718NoneOral LD50 (RABBIT) 18 g/kgOral LD50 (RAT) 30 g/kgOral LD50 (RAT) 2.91 g/kgOral LD50 (RAT) 1,400 mg/kgInhalation LC50 (RAT, 4 h) 8000 ppmIrritantCentral nervous system, Irritant, LungNTP CarcinogenIARC CarcinogenNoNoNoNoNoNoNoNoNoNoNoNoNoGroup 2BOSHA Carcinogen(Specifically Regulated)NoNoNoNoNoNoNoProduct name: Loctite(R) 242(R) Threadlocker Medium StrengthPage 4 of 6http://www.techni-tool.com

http://www.techni-tool.com12. ECOLOGICAL INFORMATIONEcological information:Not available.13. DISPOSAL CONSIDERATIONSInformation provided is for unused product only.Recommended method of disposal:Follow all local, state, federal and provincial regulations for disposal.Hazardous waste number:Not a RCRA hazardous waste.14. TRANSPORT INFORMATIONThe transport information provided in this section only applies to the material/formulation itself, and is not specific to anypackage/configuration.U.S. Department of Transportation Ground (49 CFR)Proper shipping name:Not regulatedHazard class or division:NoneIdentification number:NonePacking group:NoneInternational Air Transportation (ICAO/IATA)Proper shipping name:Hazard class or division:Identification number:Packing group:Not regulatedNoneNoneNoneWater Transportation (IMO/IMDG)Proper shipping name:Hazard class or division:Identification number:Packing group:Not regulatedNoneNoneNone15. REGULATORY INFORMATIONUnited States Regulatory InformationTSCA 8 (b) Inventory Status:TSCA 12 (b) Export Notification:CERCLA/SARA Section 302 EHS:CERCLA/SARA Section 311/312:CERCLA/SARA Section 313:CERCLA Reportable quantity:California Proposition 65:All components are listed or are exempt from listing on the Toxic Substances Control ActInventory.None above reporting de minimisNone above reporting de minimisImmediate Health, Delayed HealthThis product contains the following toxic chemicals subject to the reporting requirements ofsection 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (40CFR 372). Saccharin (CAS# 81-07-2). Cumene hydroperoxide (CAS# 80-15-9).Cumene hydroperoxide (CAS# 80-15-9) 10 lbs. (4.54 kg)This product contains a chemical known in the State of California to cause cancer. Thisproduct contains a chemical known to the State of California to cause birth defects or otherreproductive harm.Canada Regulatory InformationCEPA DSL/NDSL Status:All components are listed on or are exempt from listing on the Canadian DomesticSubstances List.16. OTHER INFORMATIONThis safety data sheet contains changes from the previous version in sections: New Safety Data Sheet format.IDH number: 230718Product name: Loctite(R) 242(R) Threadlocker Medium StrengthPage 5 of 6http://www.techni-tool.com