Transcription
SWRSIDEWALL RETURN REGISTERTRANSITION IN DUCT (NOTDIRECTION OF AIRFLOW)SARSIDEWALL SUPPLY REGISTERSB400INDICATES A SIZE "B" SUPPLYDIFFUSER SET FOR 400 CFMFIRE DAMPER (SINGLE LINE DUCT)(LISTED TO MATCH PARTITION RATING)RB100INDICATES A SIZE "B" RETURNREGISTER SET FOR 100 CFMFDFIRE DAMPER (DOUBLE LINE DUCT)(LISTED TO MATCH PARTITION RATING)EA50INDICATES A SIZE "A" EXHAUSTREGISTER SET FOR 50 CFMFSDFIRE/SMOKE DAMPER (SINGLE LINE DUCT)(LISTED TO MATCH PARTITION RATING)FIRE/SMOKE DAMPER (DOUBLE LINE)(LISTED TO MATCH PARTITION RATING)SINGLE LINE DUCT ROUTED INHORIZONTAL 2 HOUR SHAFT.FDFSDDUCT TERMINATIONPREFILTER EFF.MERV 11 (60%)SUPPLY FANTOTAL AIRFLOW (CFM)O.A. AIRFLOW (CFM)E.S.P.T.S.P.MOTOR (HP)2,0003001.01.75"2COOLING COILENTERING AIR DB (ºF)ENTERING AIR WB (ºF)LEAVING AIR DB (ºF)LEAVING AIR WB (ºF)TOTAL CAPACITY (MBH)SENSIBLE CAPACITY (MBH)80.0ºF67.0ºF52.0ºF51.8ºF90,00058,000UNIT DISCHARGELEAVING AIR DB (ºF)LEAVING AIR WB (ºF)68.0ºF58.5ºFHEATINGTYPEENTERING AIR DB (ºF)LEAVING AIR DB (ºF)TOTAL CAPACITY (MBH)HEAT PUMP60ºF85ºF54,250AUXILIARY HEATTYPEENTERING AIR DB (ºF)LEAVING AIR DB (ºF)TOTAL CAPACITY (MBH)ELECTRIC INPUTELECTRIC60ºF85ºF54,25010 KWPOWER TYPEELECTRICALMCAMOCPEMERGENCY480/3/6021301. REFER TO SPECIFICATIONS FOR ADDITIONAL REQUIREMENTS.2. PROVIDE MANUFACTURER AND MODEL SPECIFIED.3. PROVIDE FACTORY SUPPLIED SPRING ISOLATORS, HUMIDISTAT,PROGRAMMABLE THERMOSTAT, HOT GAS BYPASS ANDDISCHARGE AIR CONTROL.4. PROVIDE UNIT WITH BACNET CONTROL TO INTERFACE WITHBUILDING BAS.5. O.A. INTAKE TO BE MIN 36" ABOVE FINISHED ROOF.CHILLED WATER COOLING COILMAX FACE VELOCITY (FPM)MIN COIL FACE AREA (SQFT)E.A.T. DB/WB (ºF)COIL L.A.T. DB/WB (ºF)TOTAL CAPACITY (BTU/HR)FLOW (GPM)E.W.T. (ºF)ROWS/FINS PER INCHMAX WTR P.D. (FT. H2O)MAX AIR S.P. (IN H2O)UV SECTION (NOTE "YESPIPING LEGENDSTEAM LINE-STEAM PRESSURE (60 PSI)DIRECTION OF WATER FLOWGCGRAVITY CONDENSATE RETURNTEEPCPUMPED CONDENSATE RETURNLATERALMCDMOISTURE CONDENSATE DRAIN LINEGUIDEHWSHOT WATER SUPPLYANCHORHWRHOT WATER RETURNPIPE TURNING DOWNCHWSCHILLED WATER SUPPLYPIPE TURNING UPCHWRCHILLED WATER 34º8/10150.80"YESMERV 11 (60% EFF.)MERV 14 (90% EFF.)HUMIDIFIERTYPECAPACITY (LB/HR)STEAM PRESSURE (PSI)REMARKS:1.INDICATES HIGH EFFICIENCY MOTOR.2. PROVIDE ALL UNITS WITH INTERNAL LIGHTS ON SINGLE CIRCUIT WITH TIMERSWITCH IN THE FAN AND ACCESS SECTIONS.3. CHILLED WATER COIL SHALL BE DESIGNED FOR 16 F WATER TEMPERATUREDROP.4. FILTERS TO MATCH UNIT CASING SIZE. FILTERS TO BE 24"x24" OR 24"x12".5. FILTER FRAMES SHALL BE "FRONT LOADING" TYPE.6. UV LIGHTS SHALL BE PROVIDED WITH DOOR SWITCH TO TURN LIGHT OFF WHENDOOR IS OPEN. PROVIDE RADIOMETER TO ALARM WHEN UV LIGHT ECK6" SQ8" SQ10" SQ12" SQ14" SQ18" SQ22" 24"CFM7520030054070012502000MAX SP.04.05.05.06.07.07.06MAX NC28282728282725RUNOUT8"x4" / 6"ø10"x6" / 8"ø14"x6" / 10"ø16"x8" / 12"ø18"x8" / 14"ø24"x10" / 16"ø28"x12" / 18"øPERFORMANCE BASIS:1. TITUS MODEL 50-F5 WITH 1/2"x1/2" EGG-CRATE CORE OR EQUAL (EXAMPLE RA)2. CONTRACTOR TO USE DUCT SPIN-IN FITTINGS WITH MANUAL VOLUME DAMPER EQUALTO FLEXMASTER CBD OR FLEXMASTER STOD (OR APPROVED EQUAL) FOR CIRCULARDUCT AND STANDARD SIDE TAKE OFF WITH MANUAL VOLUME DAMPER FOR RECTANGULARRUNOUT. SEE DETAIL.3. FACE SIZE TO BE 24"X24" IN ALL LAY IN CEILING LOCATIONS TO FIT WITHIN THE GRID.STEAM GRID20010LOUVERED-FACE CEILING DIFFUSER SCHEDULESYMBOLADAPTER/NECK SIZE6"ø / 9"x9"SA8"ø / 9"x9"SB10"ø / 12"x12"SC12"ø / 12"x12"SD12"ø / 15"x15"SESJ8"øSK10"øPERFORMANCE BASIS:FACESIZEMAXCFMMAXNCMAXSPTHROWRUNOUT .09.10.094-WAY BLOW4-WAY BLOW4-WAY BLOW4-WAY BLOW4-WAY BLOWLAMINARLAMINAR6"ø / 8"x4"8"ø / 10"x6"10"ø / 12"x8"12"ø / 16"x8"12"ø / 18"x18"8"ø10"ø1. DIFFUSERS DESIGNATED WITH A SYMBOL ONLY ARE TITUS TMS OR EQUAL (EXAMPLE SA).2. CONTRACTOR TO USE DUCT SPIN-IN FITTINGS WITH MANUAL VOLUME DAMPER EQUALTO FLEXMASTER CBD OR FLEXMASTER STOD (OR APPROVED EQUAL) FOR CIRCULAR DUCTAND STANDARD SIDE TAKE OFF WITH MANUAL VOLUME DAMPER FOR RECTANGULARRUNOUT. SEE DETAIL.MIKAL MALIKHCA DESIGN MANAGER:3. FACE SIZE SHALL BE 24"X24" IN ALL LAY IN CEILING LOCATIONS TO FIT WITHIN GRIDS.DRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:06 PMDATE:09 / 10 / 2021RETURN & EXHAUST REGISTERSGLYCOL COOLING COILMAX FACE VELOCITY (FPM)MIN COIL FACE AREA (SQFT)E.A.T. DB/WB (ºF)COIL L.A.T. DB/WB (ºF)TOTAL CAPACITY (BTU/HR)FLOW (GPM)E.W.T. (ºF)ROWS/FINS PER INCHMAX WTR P.D. (FT. H2O)MAX AIR S.P. (IN H2O)UV SECTION (NOTE 6)FILTER SECTIONSPRE-FILTER EFFICIENCYFINAL FILTER EFFICIENCYINDICATES EXISTING AIRDISTRIBUTION DEVICE TO BEREBALANCED TO 100 CFMEACH.100MANUAL VOLUME DAMPERHCA# 346100009GTG# 3749300A/C-1AAONRN-0081,250INDICATES NEW WORK TO BECONNECTED TO EXISTING WORKAT THIS POINT.3700 S. MAIN ST, BLACKSBURG, VA 24060INDENTIFICATIONMANUFACTURERMODELWEIGHT (LBS)RETURN / EXHAUST GRILLESURGERY EXPANSION & RENOVATIONDATENAMECHECKED BY:RESPONSIBILITY: Author07/20/21DX ROOFTOP UNIT14,50045043º52 145,00011.6140º2/1015.00.15"SUPPLY DIFFUSER (4-WAY)ARCHITECTURECONTROL DAMPER Copyright by Gould Turner Group - 2021MANUAL VOLUME DAMPER615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210MVDNOT FORCONSTRUCTIONBRANCH TAP OFF MAIN W/DUCTEXTRACTOR OR SPIN-IN FITTINGW/DAMPER (LOW PRESSURE)GOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -HUMIDISTATMVDPREHEAT COILCFMMAX FACE VELOCITY (FPM)E.A.T. DB/WB (ºF)COIL L.A.T. DB/WB (ºF)TOTAL CAPACITY (BTU/HR)FLOW (GPM)E.W.T. (ºF)ROWS/FINS PER INCHMAX WTR P.D. (FT. H2O)MAX AIR S.P. (IN H2O)REVISIONS:HDOUBLE LINE TO SINGLELINE DUCTWORKBRASFIELD & GORRIETEMP SENSORNOAIR BLENDER SECTIONPROVIDE CHILLER WITH HOT GAS BYPASSSLEWISGALE HOSPITAL MONTGOMERY3ADJUSTABLE T'STATVENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comSTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comRYAN MCGUIRE2. PROVIDE BACNET CHILLER CONTROLS GATEWAY TO INTERFACEWITH BUILDING BAS.THCA CONSTRUCTION MANAGER:REMARKS:1. PROVIDE CHILLER WITH STARTER AND DISCONNECT.DUCT TURNING DOWN TO SIDEWALLREGISTER AT FLOOR2950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD JOHNSON9.8416.102x1 FAN ARRAY12,2752221,8002.52@5480/3/60EMERGENCY2 (1 PER FAN)FULL RADIUS TURN750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK HILNEREER (BTU/WH)NPLV (BTU/WH)RETURN FANCFMSIZEMOTOR RPMTOTAL S.P. (IN H2O)MIN. MOTOR HORSEPOWERELECTRICALPOWER TYPEVFDROUND DUCT TURNING DOWN214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERSEMERGENCY480/3/60103110STAGEDSQUARE ELBOWW/TURNING VANESI.C. THOMASSON ASSOCIATES, INC.ELECTRICALTYPEVOLTAGEMCAMOCPSTARTER TYPE95 F42x1 FAN ARRAY2451,8005.00"3.00"8.00"2 @ 15480/3/60EMERGENCY2 (1 PER FAN)45 FULL RADIUS TURNSTANLEY D. LINDSEY & ASSOCIATES, LTD.CONDENSERAMBIENT TEMP.FANSSUPPLY FANSIZEMOTOR RPMINTERNAL S.P. (IN H2O)EXTERNAL S.P. (IN H2O)TOTAL S.P. (IN H2O)MIN. MOTOR HORSEPOWERELECTRICALPOWER TYPEVFDRECTANGULAR DUCT TURNING DOWNKIMLEY-HORN AND ASSOCIATES, INC.70443415AHU-6JCI425"L x 111"W x 71"H14,000SURGERY14,50012,2752,22514,500GENERAL CONTRACTORSEVAPORATORFLOW (GPM)E.W.T. (ºF)L.W.T. (ºF)MAX. P.D. (FT)UNIT NO.MANUFACTURERAPPR. UNIT SIZEAPPR. UNIT WEIGHT (LBS.)SERVICETOTAL SUPPLY (CFM)TOTAL RETURN (CFM)O.A. MINIMUM (CFM)O.A. MAXIMUM (CFM)DUCTWORK LEGENDM,P,E & T CONSULTANTACC-113030% PROPYLENE GLYCOL121"L x 88"W x 95"H6,000CHILLED WATER AIR HANDLING UNIT SCHEDULESTRUCTURAL CONSULTANTDESIGNATIONTYPENOMINAL CAPACITY (TONS)GLYCOL CONCENTRATIONUNIT DIMENSIONSAPPR. OPERATING WEIGHT (LBS)AIR COOLEDSCROLL1CIVIL CONSULTANTREFRIGERATION MACHINEHVAC - SCHEDULESM001
REMARKS:1. REFER TO SPECIFICATIONS FOR ACCESSORIES2. CRU SHALL BE DUPLEX TYPE WITH FACTORY MOUNTED CONTROL PANEL INCLUDING STARTERS AND DISCONNECTS. SEE GVFDMIKAL MALIKHCA DESIGN MANAGER:DRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:08 PM2. REFER TO SPECIFICATIONS AND DETAILS FOR PIPING, VALVES AND ACCESSORIES. Copyright by Gould Turner Group - 2021HCA# 346100009GTG# 37493003700 S. MAIN ST, BLACKSBURG, VA M7050TDH FT H2O--NPSH34ºFTEMPERATURE150CASING WORKING PRESS3MIN MOTOR HP480/3/60VOLTAGE/PHASE1,800RPMPOWER CATES PREMIUM EFFICIENCY MOTOR.2SURGERY EXPANSION & RENOVATIONEND SUCTION SERIES 1510LEWISGALE HOSPITAL MONTGOMERYCRU-14MECH. PENTHOUSE--,----2003,6001480/3/6075CAST IRONDUPLEX1VENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comSTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comRYAN MCGUIREDESIGNATIONLOCATIONCAPACITY EDRGPMDISCHARGE PRESSURE (PSI)TEMPERATUREPUMP RPMMIN. MOTOR HPELECTRICALRECEIVER SIZE (GALLONS)RECEIVER TYPEPUMP SETPUMP SCHEDULEHCA CONSTRUCTION MANAGER:CONDENSATE RETURN UNIT SCHEDULESTRUCTURAL CONSULTANTREMARKS:2950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD 0/1/60NOYESBACKDRAFTNONECURBEMERGENCYCOOK750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK /1/60NOYESBACKDRAFTNONECURBEMERGENCYCOOK214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERSEF14-1ISOLATION23751.00"2,2406770 CPV1/3120/1/60NONONONEBACKDRAFTSPRING ISO.EMERGENCYCOOKSTANLEY D. LINDSEY & ASSOCIATES, LTD.EF-CSCENT. STERILE23,0001.25"1,22165180 CPV1 1/2208/1/60NOYESNONEBACKDRAFTSPRING ISO.EMERGENCYCOOKFAN NUMBERSERVICETYPECFMSP-IN H2OMAX FAN RPMMAX OUTLET VEL/TS (MPH)SIZEMIN MOTOR HPELECTRICALINLET SCREENOUTLET SCREENINLET DAMPER-TYPEOUTLET DAMPER-TYPEOTHERPOWER TYPEMANUFACTURERI.C. THOMASSON ASSOCIATES, INC.BELTED VENT SETDATENAMECHECKED BY:RESPONSIBILITY: Author08/31/212. CONTROLS TO BE DDC WITH TEMPERATURE RESET UTILIZING TWO STEAMCONTROL VALVES WITH STAINLESS STEEL TRIM. ONE VALVE SIZED FOR1/3 OF LOAD AND THE OTHER FOR 2/3 OF THE LOAD.2KIMLEY-HORN AND ASSOCIATES, INC.REMARKS:1. REFER TO SPECIFICATIONS AND DETAILS FOR ACCESSORIESCENTRIFUGAL615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210ARCHITECTURENOT FORCONSTRUCTIONGOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -DATE:09 / 10 / 2021REVISIONS:BRASFIELD & GORRIEGENERAL CONTRACTORSCV-1440MECH. PENTHOUSEAHU-14--115º140º0.000252.5-,--75-B&G U-TUBE1CIVIL -BTUHENT WATER TEMP ºFLVG WATER TEMP ºFFOULING FACTORMAX WATER PD-FT H2OSTEAM #/HRSTEAM PSIG @ CONT VALVESTEAM PSIG @ CONVERTERMANUFACTURERFAN SCHEDULEM,P,E & T CONSULTANTCONVERTER SCHEDULEHVAC - SCHEDULESM002
NN.1EETFFUWHHXLOWESTPRIORITY2FS2FSTWO HOUR RATED FIRE BARRIER2F2F2F4ONE HOUR RATED FIRE BARRIER1F1F1F5ONE HOUR RATED FIRE & SMOKE BARRIER1FS1FS1FS6ONE HOUR RATED FIRE BARRIER (INCIDENTAL USE/HAZARDOUS AREA)1HR1HR1HR7SMOKE PARTITIONNSNSNS8PARTITION TO CEILING - STUDS TODECK, STOP GYPSUM BOARD 4" ABOVECEILING.17DEMOLITION NOTES:EXISTING MEDICAL CHILLER TOBE RELOCATED TO NEW ROOF.1. EXISTING ROUTING AND LOCATION OF EXISTING DUCTWORK, EQUIPMENT, ETC. SHOWN ARE BASED ONTHE PREVIOUS CONTRACT DOCUMENTS. CONTRACTOR TO VERIFY EXISTING CONDITIONS FORDISCREPANCIES.2. ALL EXISTING WALLS, CEILINGS, FLOOR SLABS, ROOF, ETC., BEING CUT OR DAMAGED UNDER THISCONTRACT TO BE PATCHED BACK TO MATCH EXISTING FINISH AND FIRE PROTECTION RATING.COORDINATE REQUIREMENTS WITH ARCHITECTURAL.515EXISTINGPROCESSCHILLER3. PRIOR TO DEMOLITION WORK COMMENCING, CONTRACTOR TO COORDINATE WITH OWNER FORDISPOSITION OF EXISTING EQUIPMENT TO BE REMOVED. CONTRACTOR TO REMOVE ITEMS TO BERETAINED BY OWNER AND TRANSPORT THEM TO A PREDETERMINED AREA FOR STORAGE BY OWNER. ALLOTHER ITEMS TO BE REMOVED FROM SITE AND DISPOSED OF AT CONTRACTOR'S EXPENSE.4. IN AREAS OF RENOVATION, THE EXISTING DUCT MAINS AND BRANCH LINES, PIPING, AND CONDUIT SHALLBE RAISED OR RELOCATED AS NECESSARY TO ALLOW FOR THE INSTALLATION OF NEW DUCTWORK ANDPIPING AND MAINTAIN NEW CEILING HEIGHTS AS SET BY THE ARCHITECTURAL PLANS.145. CONTRACTOR TO REMOVE EXISTING MECHANICAL EQUIPMENT AND APPURTENANCES AS INDICATEDFROM EXISTING BUILDING. PHASING SHALL BE COORDINATED WITH CONSTRUCTION SCHEDULE ANDHOSPITAL.6. CONTRACTOR TO COORDINATE WITH ELECTRICAL CONTRACTOR FOR REMOVAL OF EXISTING CONDUITAND WIRING FEEDING EXISTING MECHANICAL EQUIPMENT TO BE REMOVED.19ARCHITECTURE7. REMOVE ALL T'STATS AND HOT WATER PIPING TO EXISTING HOT WATER COILS REMOVED. CAP PIPING ATMAINS.8. COORDINATE WITH GENERAL CONTRACTOR AND HOSPITAL STAFF FOR PHASING AND SHUT DOWN OFEXISTING AHU.9. PRIOR TO ANY WORK COMMENCING USE DUCT TRAVERSES TO MEASURE AIRFLOW AT LOCATIONSINDICATED ON PLANS BY . TYPICAL OF 3 LOCATIONS. IN ADDITION, MEASURE SUPPLY, RETURN ANDEXHAUST AIR FLOWS OF UNIT AHU-4A. RECORD READINGS AND FURNISH TO ENGINEER FOR REVIEW.RETURN GRILLE TO BEREMOVED (TYP.)13SUPPLY DIFFUSER TO BEREMOVED (TYP.)EXISTING DUCT UP TO EXISTINGEXHAUST FAN EF-1 TO REMAIN.DATE:2FS09 / 10 / 2021REVISIONS:32S13.9 Copyright by Gould Turner Group - 2021N.0TWO HOUR RATED FIRE & SMOKE BARRIER2S615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210K.622SNOT FORCONSTRUCTIONK.7TWO HOUR RATED FIRE BARRIER - SHAFTWALLGOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -J.9J.81BRASFIELD & GORRIEHIGHESTPRIORITY- SEE SHEET A4.01GENERAL CONTRACTORSPARTITION LEGEND18EXISTING VAV BOX 4A-02 ANDASSOCIATED PIPING ANDTHERMOSTAT TO BE REMOVED.EXISTINGAHU-4DEMOLITIONHVAC - FIRST FLOOR PLAN - DEMOLITION - PART A8'16'AECDHCA# 346100009GTG# 37493003700 S. MAIN ST, BLACKSBURG, VA 24060SURGERY EXPANSION & RENOVATION2950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD JOHNSON24'MIKAL MALIK4'BDRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:12 PMI.C. THOMASSON ASSOCIATES, INC.2A0HCA DESIGN MANAGER:SNWLEWISGALE HOSPITAL MONTGOMERYEXISTING TO REMAINVENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comSTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comRYAN MCGUIREEXISTING 42"x20" RETURN DUCT UP TO EXISTINGRTU-4A ON ROOF ABOVE TO REMAIN.HCA CONSTRUCTION MANAGER:DEMOLITION LEGEND750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK HILNERCIVIL CONSULTANTEXISTING 40"x20" SUPPLY DUCT DOWN FROMEXISTING RTU-4A ON ROOF ABOVE TO REMAIN.214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERSNAME12.3STANLEY D. LINDSEY & ASSOCIATES, LTD.STRUCTURAL CONSULTANTDATE13.3CHECKED BY:RESPONSIBILITY: Author07/20/21EXISTING VAV BOX 4A-09 ANDASSOCIATED PIPING ANDTHERMOSTAT TO BE REMOVED.KIMLEY-HORN AND ASSOCIATES, INC.M,P,E & T CONSULTANTEXISTING EXHAUST GRILLETO BE REMOVED (TYP.)FIRST FLOOR KEY PLANHVAC - 1ST FLOOR PLAN- A - DEMOLITIONM101
WZ2FS2FSTWO HOUR RATED FIRE BARRIER2F2F2F4ONE HOUR RATED FIRE BARRIER1F1F1F5ONE HOUR RATED FIRE & SMOKE BARRIER1FS1FS1FS6ONE HOUR RATED FIRE BARRIER (INCIDENTAL USE/HAZARDOUS AREA)1HR1HR1HR7SMOKE PARTITIONNSNSNS8PARTITION TO CEILING - STUDS TODECK, STOP GYPSUM BOARD 4" ABOVECEILING.XLOWESTPRIORITYEXISTING SIDEWALL SUPPLYDIFFUSER TO REMAIN.EXISTING EXHAUST GRILLE TOBE REMOVED.EXISTING RETURN GRILLE TOBE REMOVED.EXISTING VAV BOX TO REMAIN.9.1454443EXISTING SUPPLY DIFFUSERTO BE REMOVED.EXISTING VAV BOX TO BEREMOVED.EXISTING SUPPLY DROP DOWN FROMEXISTING VAV BOX 7-10 TO REMAIN.8.4ARCHITECTUREEXISTING SUPPLY DROP DOWN FROMEXISTING VAV BOX 7-11 TO REMAIN.EXISTING EXHAUSTBRANCH TO BE REMOVEDEXISTING HOT SUPPLY DUCT DOWNFROM MECHANICAL ROOM ABOVE.TO REMAIN.EXISTING SUPPLY DIFFUSERTO BE REMOVED. (TYP.)EXISTING COLD SUPPLY DUCT DOWNFROM MECHANICAL ROOM ABOVE.TO REMAIN.SNWEXISTING DUAL DUCT MIXINGBOX TO BE REMOVED (TYP.)HVAC - FIRST FLOOR PLAN - DEMOLITION - PART C04'8'16'DATE:2FS09 / 10 / 2021REVISIONS:32S Copyright by Gould Turner Group - 20211.15TWO HOUR RATED FIRE & SMOKE BARRIER2S615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210V22SNOT FORCONSTRUCTION1.11TWO HOUR RATED FIRE BARRIER - SHAFTWALLGOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -S1BRASFIELD & GORRIEHIGHESTPRIORITY- SEE SHEET A4.01GENERAL CONTRACTORSPARTITION LEGEND24'EEXISTING STEAM CAPTURE HOODSABOVE EXISTING WASHERS TOREMAIN (TYP. OF 2)16'24'CIVIL CONSULTANTEXISTING RETURN GRILLE TOBE REMOVED. (TYP.)DEMOLITION LEGENDEXISTING TO REMAINDEMOLITION6.3 DIFFUSEREXISTING SUPPLYTO BE REMOVED. (TYP.)DEMOLITION NOTES:EXISTING VAV BOX TO REMAIN.ALL EXISTING DUCTWORK,THERMOSTATS, AND APPURTENANCESASSOCIATED WITH EXISTING ROOFTOPPACKAGED UNIT TO BE REMOVED.1. EXISTING ROUTING AND LOCATION OF EXISTING DUCTWORK, EQUIPMENT, ETC. SHOWN ARE BASED ONTHE PREVIOUS CONTRACT DOCUMENTS. CONTRACTOR TO VERIFY EXISTING CONDITIONS FORDISCREPANCIES.2. ALL EXISTING WALLS, CEILINGS, FLOOR SLABS, ROOF, ETC., BEING CUT OR DAMAGED UNDER THISCONTRACT TO BE PATCHED BACK TO MATCH EXISTING FINISH AND FIRE PROTECTION RATING.COORDINATE REQUIREMENTS WITH ARCHITECTURAL.A3. PRIOR TO DEMOLITION WORK COMMENCING, CONTRACTOR TO COORDINATE WITH OWNER FORDISPOSITION OF EXISTING EQUIPMENT TO BE REMOVED. CONTRACTOR TO REMOVE ITEMS TO BERETAINED BY OWNER AND TRANSPORT THEM TO A PREDETERMINED AREA FOR STORAGE BY OWNER. ALLOTHER ITEMS TO BE REMOVED FROM SITE AND DISPOSED OF AT CONTRACTOR'S EXPENSE.4. IN AREAS OF RENOVATION, THE EXISTING DUCT MAINS AND BRANCH LINES, PIPING, AND CONDUIT SHALLBE RAISED OR RELOCATED AS NECESSARY TO ALLOW FOR THE INSTALLATION OF NEW DUCTWORK ANDPIPING AND MAINTAIN NEW CEILING HEIGHTS AS SET BY THE ARCHITECTURAL PLANS.BNSEDRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:17 PMC5. CONTRACTOR TO REMOVE EXISTING MECHANICAL EQUIPMENT AND APPURTENANCES AS INDICATEDFROM EXISTING BUILDING. PHASING SHALL BE COORDINATED WITH CONSTRUCTION SCHEDULE ANDHOSPITAL.WHVAC - FIRST FLOOR PLAN - DEMOLITION - PART D04'8'16'24'D6. CONTRACTOR TO COORDINATE WITH ELECTRICAL CONTRACTOR FOR REMOVAL OF EXISTING CONDUITAND WIRING FEEDING EXISTING MECHANICAL EQUIPMENT TO BE REMOVED.7. REMOVE ALL T'STATS AND HOT WATER PIPING TO EXISTING HOT WATER COILS REMOVED. CAP PIPING ATMAINS.HCA# 346100009GTG# 37493002950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD JOHNSON2A3700 S. MAIN ST, BLACKSBURG, VA 240608'SURGERY EXPANSION & RENOVATION4'LEWISGALE HOSPITAL MONTGOMERY0VENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comSTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comRYAN MCGUIREEXISTING RETURN GRILLE TOREMAIN. (TYP.)HVAC - FIRST FLOOR PLAN - DEMOLITION - PART BHCA CONSTRUCTION MANAGER:NWMIKAL MALIKDATECHECKED BY:NAMEEXISTING SUPPLY DIFFUSERTO REMAIN. (TYP.)SRESPONSIBILITY: Author7.4E07/20/21EXISTING EXHAUST GRILLE TOREMAIN. (TYP.)750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK HILNERSTRUCTURAL CONSULTANTEXISTING EXHAUST DUCT UPTO FAN ON ROOF ABOVE TOREMAIN.214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERSQHCA DESIGN MANAGER:NI.C. THOMASSON ASSOCIATES, INC.K.6STANLEY D. LINDSEY & ASSOCIATES, LTD.EXISTING RETURN GRILLETO BE REMOVED. (TYP.)KIMLEY-HORN AND ASSOCIATES, INC.M,P,E & T CONSULTANTEXISTING STEAM CAPTURE HOODSABOVE EXISTING STERILIZERS TOREMAIN (TYP. OF 2)8. COORDINATE WITH GENERAL CONTRACTOR AND HOSPITAL STAFF FOR PHASING AND SHUT DOWN OFEXISTING AHU.9. PRIOR TO ANY WORK COMMENCING USE DUCT TRAVERSES TO MEASURE AIRFLOW AT LOCATIONSINDICATED ON PLANS BY . TYPICAL OF 12 LOCATIONS. IN ADDITION, MEASURE SUPPLY, RETURN ANDEXHAUST AIR FLOWS OF UNITS: AHU-7, AHU-8, AND AHU-12. RECORD READINGS AND FURNISH TOENGINEER FOR REVIEW.FIRST FLOOR KEY PLANHVAC - 1ST FLOOR PLAN- B,C,D - DEMOLITIONM102
5EXISTING MEDICAL CHILLER ONGRADE TO BE RELOCATED TOROOF OF NEW ADDITION.2TWO HOUR RATED FIRE & SMOKE BARRIER32S2S2S2FS2FS2FSTWO HOUR RATED FIRE BARRIER2F2F2F4ONE HOUR RATED FIRE BARRIER1F1F1F5ONE HOUR RATED FIRE & SMOKE BARRIER1FS1FS1FS6ONE HOUR RATED FIRE BARRIER (INCIDENTAL USE/HAZARDOUS AREA)1HR1HR1HR7SMOKE PARTITIONNSNSNS8PARTITION TO CEILING - STUDS TODECK, STOP GYPSUM BOARD 4" ABOVECEILING.1313.918LOWESTPRIORITYEXISTING RTU-4 INTAKE ANDRELIEFHOODS TO REMAIN.2AAEXISTINGEXHAUST FAN TOREMAIN.BCDEXISTING RTU-4ATO REMAIN.DATE:ARCHITECTUREEXISTINGRTU-4AFIRST FLOOR KEY PLANDEMOLITION LEGEND13.3EXISTING TO REMAIN12.3DEMOLITION Copyright by Gould Turner Group - 2021TWO HOUR RATED FIRE BARRIER - SHAFTWALL615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210EXISTINGEXHAUST FAN TOREMAIN.1GOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -HIGHESTPRIORITYBRASFIELD & GORRIE19- SEE SHEET A4.01GENERAL CONTRACTORSPARTITION LEGENDNOT FORCONSTRUCTION1409 / 10 / 2021REVISIONS:15DEMOLITION NOTES:S1.11N.1VEXISTINGEXHAUST FAN TOREMAIN.1.15Z1. EXISTING LOCATION OF EXISTING EQUIPMENT, ETC. SHOWN ARE BASED ON THE PREVIOUS CONTRACTDOCUMENTS. CONTRACTOR TO VERIFY EXISTING CONDITIONS FOR DISCREPANCIES.ALL EXISTING ROOF, ETC., BEING CUT OR DAMAGED UNDER THIS CONTRACT TO BE PATCHED BACK TO2. MATCH EXISTING FINISH AND FIRE PROTECTION RATING. COORDINATE REQUIREMENTS WITHARCHITECTURAL.3. PRIOR TO DEMOLITION WORK COMMENCING, CONTRACTOR TO COORDINATE WITH OWNER FORDISPOSITION OF EXISTING EQUIPMENT TO BE REMOVED. CONTRACTOR TO REMOVE ITEMS TO BERETAINED BY OWNER AND TRANSPORT THEM TO A PREDETERMINED AREA FOR STORAGE BY OWNER. ALLOTHER ITEMS TO BE REMOVED FROM SITE AND DISPOSED OF AT CONTRACTOR'S EXPENSE.4. IN AREAS OF RENOVATION, THE EXISTING DUCT MAINS AND BRANCH LINES, PIPING, AND CONDUIT SHALLBE RAISED OR RELOCATED AS NECESSARY TO ALLOW FOR THE INSTALLATION OF NEW DUCTWORK ANDPIPING AND MAINTAIN NEW CEILING HEIGHTS AS SET BY THE ARCHITECTURAL PLANS.PRIVATEPRIVATEPAT.PAT.TLT.RM. RM.216T4051416PRIVATEPAT.PRIVATEPAT.TLT. RM. RM.T4052 218PRIVATEPRIVATEPAT. PAT.RM. RM. TLT.420 220 T4055PRIVATEPRIVATEPAT. PAT.TLT. RM. RM.T4056 222PRIVATEPRIVATEPAT.PAT.RM. RM. TLT.T4060424HCA# 346100009GTG# 37493003700 S. MAIN ST, BLACKSBURG, VA 24060SURGERY EXPANSION & RENOVATIONLEWISGALE HOSPITAL MONTGOMERY2950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD JOHNSONVENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comRYAN MCGUIRESTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comSTAIRT2050NWE39HCA CONSTRUCTION MANAGER:6.3SDRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:20 PMEXISTING PACKAGED DX ROOFTOPUNIT TO BE REMOVED.MIKAL MALIK7.4750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK HILNERCIVIL CONSULTANTEXISTING RTU-12TO REMIAIN.214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERS8.4HCA DESIGN MANAGER:EXISTINGRTU-12STRUCTURAL CONSULTANTNAMEDATEMECH.RM. 6T20178861.28CHECKED BY:RESPONSIBILITY: Author09/01/219.1I.C. THOMASSON ASSOCIATES, INC.AASTANLEY D. LINDSEY & ASSOCIATES, LTD.Q7. COORDINATE WITH GENERAL CONTRACTOR AND HOSPITAL STAFF FOR PHASING AND SHUT DOWN OFEXISTING MECHANICAL EQUIPMENT.DDGGKIMLEY-HORN AND ASSOCIATES, INC.6. CONTRACTOR TO COORDINATE WITH ELECTRICAL CONTRACTOR FOR REMOVAL OF EXISTING CONDUITAND WIRING FEEDING EXISTING MECHANICAL EQUIPMENT TO BE REMOVED.M,P,E & T CONSULTANT5. CONTRACTOR TO REMOVE EXISTING MECHANICAL EQUIPMENT AND APPURTENANCES AS INDICATEDFROM EXISTING BUILDING. PHASING SHALL BE COORDINATED WITH CONSTRUCTION SCHEDULE ANDHOSPITAL.HVAC - ROOF PLAN - DEMOLITION04'8'16'24'ROOF PLAN DEMOLITIONM103
N.0NEETFFUWHH2FSTWO HOUR RATED FIRE BARRIER2F2F2F4ONE HOUR RATED FIRE BARRIER1F1F1F5ONE HOUR RATED FIRE & SMOKE BARRIER1FS1FS1FS6ONE HOUR RATED FIRE BARRIER (INCIDENTAL USE/HAZARDOUS AREA)1HR1HR1HR7SMOKE PARTITIONNSNSNS8PARTITION TO CEILING - STUDS TODECK, STOP GYPSUM BOARD 4" ABOVECEILING.FDMVDDSD2F17MVDTDR1A-114FDMVDNEW WORK NOTES:PACU #41A-104PACU #51A-105PACU #61A-106PACU #71A-107PACU #81A-108PACU #91A-109PACU #101A-110PACU #111A-111PACU FS1FS1FS1FS1FS1FS(400/300) INDICATES EXISTING VAV BOX TO BE REBALANCED TO 400 CFM MAXIMUM FLOW AND 300 CFMMINIMUM FLOW.4.ALL DUCT AND PIPE TO BE INSTALLED AT A MINIMUM OF 6” CLEAR TO RATED WALLS TO ALLOW FORINSPECTION OF PARTITION ASSEMBLIES. ALL UTILITIES SHALL BE LOCATED SO THAT ACCESS ISMAINTAINED TO ADJACENT WALL SURFACES AND TO ALL ACCESS DOORS.5.CONTRACTOR TO VERIFY POST CONSTRUCTION AIRFLOWS MATCH PRE-TAB AIRFLOW AT LOCATIONSINDICATED ON PLANS BY . TYPICAL OF 3 LOCATIONS.1FS151FS1FS1FS1FS1FSINDICATES EXISTING AIR DISTRIBUTION DEVICE TO BE REBALANCED TO 100 CFM EACH.3.51FS100141FSDSD14-131FS2.INDICATES NEW WORK TO BE CONNECTED TO EXISTING WORK AT THIS A-117FD--"x--" EXHAUST DUCT UPTO EF14-2 ON S14-112-POSITION CONTROLDAMPERARCHITECTURE1FSSOIL FD1HREQUIP.ALCOVE1A-131PACU #131A-1191HR1HRPACU #141A-1201FS--"x--" EXHAUST DUCT UPTO EF14-1 ON DPASS.1A-12664"x24" SUPPLY DUCTDOWN FROM AHU-14 INPENTHOUSE ABOVE.PASS.1A-1132FPACU #31A-1031HRPACU #21A-1021HRPACU RR.1A-1441F1FNSNSNS1FNS2-POSITION MAJOR O.R.91A-137PASS.1A-136NSMAJOR O.R.81A-133NSNSNSNSFULLY MODULATINGCONTROL DAMPER1FS1FSDSDFSDDATE:2FS09 / 10 / 20212FSXLOWESTPRIORITYREVISIONS:32S13.9 Copyright by Gould Turner Group - 2021K.6TWO HOUR RATED FIRE & SMOKE BARRIER2S615 3RD AVE SOUTH, SUITE 700NASHVILLE , TENNESSEE 37210K.722SNOT FORCONSTRUCTIONJ.8J.9TWO HOUR RATED FIRE BARRIER - SHAFTWALLGOULD TURNER GROUP, P.C.DESIGN DEVELOPMENT -56"x36" RETURN DUCT UPTO AHU-14 INPENTHOUSE ABOVE.1BRASFIELD & GORRIEHIGHESTPRIORITY- SEE SHEET A4.01GENERAL CONTRACTORSPARTITION TINGAHU-41FMVDFULLY MODULATINGMECHCONTROL " RETURN DUCTDOWN IN CHASETO --"Hx--W" SIDE WALLDIFFUSER MOUNTEDAT 18" A.F.F. ANDBALANCED TO --- CFM.(TYP. OF RFD1F1FCAP1F1F1F1FNEW WORKLEGENDN.1CIVIL CONSULTANTEXISTING TO REMAINNEW CONSTRUCTIONSNWHVAC - FIRST FLOOR PLAN - PART A04'8'16'24'E2ADRAWING FILE: BIM 360://3749300 - LG Mont/ICT 210237 MP20 Central.rvtPLOTTED ON: 9/9/2021 2:41:29 PMCDMIKAL MALIKBHCA DESIGN MANAGER:AHCA# 346100009GTG# 37493003700 S. MAIN ST, BLACKSBURG, VA 24060NSEXAM#7SURGERY EXPANSION & RENOVATIONNSNS12.3VENDOR INFORMATIONSTERIS - SURGICAL BOOMS & CSS EQUIP.Patrick Down: Patrick Down@steris.comQUANTUM MEDICAL - STORAGERachel Sanvidge: RachelS@quantummedical.comAMBIANCE GROUP - ARTWORKKatherin Erickson: KatherineE@ambianceart.comSTANDARD TEXTILE - CUBICLE CURTAINSScott Stapleton: SStapelton@standardtextile.comRYAN 8750 OLD HICKORY BLVD. BLDG. 1 STE. 175BRENTWOOD, TN 37027MANAGER: MARK HILNER1HRNSNAMECHECKED BY:NSLOCKERS13.3NS1HRJ.C.TLT.STRUCTURAL R1HRNSNSCAP1HRCAPNSNSTLT.HCA CONSTRUCTION : R#5STERILESTORAGE1A-1401HRNSUP2F1HRCORR.214 OCEANSIDE DR.NASHVILLE, TN 37204MANAGER: CHRIS AKERS4A-094A-02LEWISGALE HOSPITAL MONTGOMERYNSSTANLEY D. LINDSEY & ASSOCIATES, LTD.1HR2950 KRAFT DRIVENASHVILLE, TN 37204MANAGER: BOYD 1HRTLT.I.C. THOMASSON ASSOCIATES, INC.FDKIMLEY-HORN AND ASSOCIATES, .R. 10)CAP1A-139M,P,E & T CONSULTANT1HRNSNSNSFD1HRNS1HRNS1HROR#61HR--"x--" EXHAUST DUCT UPTO EF14-2 ON ROOFABOVE.FIRST FLOOR KEY PLANHVAC - 1ST FLOOR PLAN-AM201
ASS.1C-10132S2FS2FS2FSTWO HOUR RATED FIRE BARRIER2F2F2F4ONE HOUR RATED FIRE BARRIER1F1F1F5ONE HOUR RATED FIRE & SMOKE BARRIER1FS1FS1FS6ONE HOUR RATED FIRE BARRIER (INCIDENTAL USE/HAZARDOUS AREA)1HR1HR1HR7SMOKE PARTITIONNSNSNS8PARTITION TO CEILING - STUDS TODECK, STOP GYPSUM BOARD 4" ABOVECEILING.NEW --"x--" RETURN DUCT TO BECONNECTED TO EXISTING --"x--"RETURN NSNSNSNSNS1FSNSNSNS8.4NS1FSNS1FS1FSNS1FSNSNEW --"x--" SUPPLY DUCT TO BECONNECTED TO EXISTING --"x--"SUPPLY DUCT1FSCORR.HVAC - FIRST FLOOR PLAN - PART C4'8'16'1FSNS24'E1FS01FSNEW --"x--" EXHAUST DUCT UPTO NEW EXHAUST FAN EF-CSON ROOF ABOVE.1FSPASS.1B-104CONNECT NEW --"x--" SUPPLY DUCTTO EXISTING --"x--" SUPPLY DUCT.1FEXISTING 48"x20" COLD SUPPLYDUCT DOWN FROM ON.1B-102FD1F1FS1FS1FSNOTE 9.1HRFD---EXISTING 60"x20" COLD SUPPLYDUCT DOWN FROM ABOVE.LOUNGE1B-103 ---1FS1FCAPNEW --"x--" EXHAUST DUCT TO BECONNECTED TO EXISTING STEAMCAPTURE HOOD. NOTE 3.CORR.NEW --"Ø SUPPLY DUCT TO BECONNECTED TO EXISTING60"x20" COLD SUPPLY SNEW --"x--" EXHAUST DUCT TO BECONNECTED TO EXISTING STEAMCAPTURE HOOD.
aaon rn-008 1,250 2,000 300 1.0 2 90,000 58,000 heat pump 60ºf 85ºf 1.75" 480/3/60 unit no. manufacturer chilled water cooling coil chilled water air handling unit schedule total supply (cfm) o.a. minimum (cfm) o.a. maximum (cfm) internal s.p. (in h2o) external s.p. (in h2o) total s.p. (in h2o) electrical remarks: service power type supply .
